'36 Ford Pickup, Chopped 2", Mustang Ii Front End, 9" Rear End, Boxed Frame on 2040-cars

Auto blog

Ford Explorer is America's new favorite police car

There is a new vehicle that you should keep an eye out for when you're going a little too fast down the Interstate. Ford's Explorer-based Police Interceptor Utility was the bestselling new law enforcement model in the country last year, and signs show that won't be changing anytime soon.
Ford sold 14,086 Interceptor Utilities in 2013, up 140% from the year before, and 10,897 Interceptor Sedans, up 31%, according to USA Today. Overall, the brand's police sales were up 48 percent, and they were enough to boost the company's law enforcement vehicle market share by 9 points to nearly 50 percent.
The success comes just a few years after it made the decision to finally retire the long-serving Crown Victoria-based cruiser for two more modern vehicles. "We had to reinvent the category," said Chris Terry of Ford Communications to Autoblog. The automaker had to convince police departments that a unibody chassis without a V8 could perform better than a model that had been a law enforcement staple for years.

Recharge Wrap-up: Ford 1.0L EcoBoost a hit in Europe; Build a tiny inverter, win $1 million

In Europe, Ford's 1.0-liter EcoBoost engine is the best-selling turbocharged gasoline engine. The three-cylinder motor powers 20 percent of new Fords sold in Europe. Earlier this year, it won its third International Engine of the Year award, and between January and June, it was sold in about 120,000 cars. So far this year, 38 percent of Fords sold in the Netherlands, 35 percent in Denmark and 32 percent in Switzerland have been powered by the 1.0-liter EcoBoost. The engine's turbocharger spins at 248,000 rpm, and provides 24 psi of pressure. The engine produces up to 138 horsepower, depending on the version. Read more in the press release below. When lithium-ion battery packs are retired from the road, remanufacturing, repurposing, and recycling are worthwhile options, according to a study by Mineta Transportation Institute. The study included a cost-benefit analysis of those three options, and found remanufacturing to be the best route. To get the most out of them, batteries should be tested and have their damaged cells replaced then put back to use. Repurposing is the second best option, using the remaining available charge for something besides cars. Recycling on its own isn't profitable, but it could make economic sense with "increased technological breakthroughs." Learn more at Recycling International or download the report here. A smaller inverter for EVs can win you $1 million. The Little Box Challenge is an open competition to build a power inverter with a density of at least 50 watts per cubic inch. Google and the Institute of Electrical and Electronics Engineers (IEEE) are offering the hefty prize to the team that builds the inverter with the highest power density within an enclosed volume of 40 cubic inches. Teams must register by September 30. Read more at Green Car Congress or learn more at the Little Box Challenge website.

Watch Ken Block's scary Rally America crash from inside the cockpit

Ken Block became famous for his series of Gymkhana videos, but he's a real racer in his own right. Block has competed many rounds in the FIA World Rally Championship and also rallied in the 2013 Rally America series. He nearly won that latter title last year - if not for a massive crash in the final event of the season.
Block and his co-driver Alex Gelsomino went into the Lake Superior Performance Rally needing a win to take the championship. However, missing a clump of dirt on the side of the road and one little word in the pace notes was all it took to catapult Block's Fiesta off the road and into a tumbling accident. Block says his initial reaction was anger because the crash came out of nowhere.
For 2014, Block is joining the FIA World Rallycross Championship for at least three rounds. He'll drive a Ford Fiesta for the Hoonigan Racing Division at the Norwegian, French and Turkish events of the 12-round championship. Former Formula One World Champion Jacques Villeneuve will also compete in the series.