2000 Ford Mustang Roush Edition 1 Of 4 Made on 2040-cars

Auto blog

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

Ford made three big mistakes in calculating MPG for 2013 C-Max Hybrid

It's been a rough time for the official fuel economy figures for the Ford C-Max Hybrid. When the car was released in 2012, Ford made a huge deal about how it would beat the Toyota Prius V, which was rated at 42 combined miles per gallon, 44 city and 40 highway. The Ford? 47 mpg across the board. How did Ford come to this place, where its Prius-beater turned into an also-ran? Well, after hearing customer complaints and issuing a software update in mid-2013, then discovering a real problem with the numbers last fall and then making a big announcement last week that the fuel economy ratings of six different 2013 and 2014 model year vehicles would need to be lowered, the C-Max Hybrid has ended up at 40 combined, 42 city and 37 highway. In other words, the Prius trumps it, as daily drivers of those two vehicles have known for a long time. The changes will not only affect the window sticker, but also the effect that the C-Max Hybrid (and the five other Ford vehicles that had their fuel economy figures lowered last week) have on Ford's compliance with greenhouse gas and CAFE rules for model year 2013 and 2014. How did Ford come to this place, where its Prius-beater turned into an also-ran? There are two technical answers to that question, which we've got below, as well as some context for how Ford's mistakes will play out in the bigger world of green vehicles. Let's start with Ford's second error, which is easy to do since we documented it in detail last year (the first, needing to do a software update, was also covered). The basic gist is that Ford used the general label rule (completely legally) to test the Fusion Hybrid and use those numbers to figure out how efficient the C-Max Hybrid is. That turned out to be a mistake, since the two vehicles are different enough that their numbers were not comparable, despite having the same engine, transmission and test weight, as the rules require. You can read more details here. Ford's Said Deep admitted that the TRLHP issue is completely separate from the general label error from last year. Now let's move on to last week's announcement. What's interesting is that the new recalculation of the MPG numbers – downward, of course – was caused by a completely separate issue, something called the Total Road Load Horsepower (TRLHP). Ford's Said Deep admitted to AutoblogGreen that the TRLHP issue had nothing to do with the general label error from last year.

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.