2012 Ford Fusion Sel on 2040-cars

Auto blog

NHTSA investigating Ford's solution to May 2014 power steering recall

The National Highway Traffic Safety Administration is investigating a complaint that Ford's response to a May 2014 recall of the 2008 to 2011 Ford Escape and Mercury Mariner doesn't quite go far enough to solve a troubling power-steering problem. Roughly a year ago, Ford recalled nearly a million vehicles after it was found that a problem with the torque sensor's communication with the power steering control module could cut steering assistance for drivers. While manual steering would still be available, the problem was enough to ask drivers to report in to have the PSCM inspected, and if necessary, replaced (along with the torque sensor, or in dramatic cases, the entire steering column). That would only happen, though, if trouble codes were being thrown. If there weren't any problems, dealers were told to simply update the PSCM's software so that any issues between it and the torque sensor would simply throw a visual and audio warning – power steering would still be maintained. The petitioner claimed that following the recall work, he still experienced a problem with the torque sensor. According to NHTSA, a claim was made that Ford didn't go far enough in its solution to the problem, and that "the software update itself may in fact cause further issues with the affected vehicle's power steering, causing it to fail, and ultimately requiring replacement of the torque sensor or entire steering column." The petition was filed in early February and is now officially being looked into by NHTSA.

Ford announces first non-pursuit-rated police car ever

Ford announced its first non-pursuit-rated Police Interceptor ever, based on the Taurus, which employs the smaller 2.0-liter EcoBoost four-cylinder engine in place of similar pursuit-rated Police Interceptors powered by naturally aspirated 3.5-liter and 3.7-liter V6s and the top-spec 3.5-liter EcoBoost V6. Officially called the Special Service Police sedan, the car was commissioned at the request of law-enforcement agencies that desire a more fuel-efficient vehicle for detectives, administrators and campus police, who don't necessarily need pursuit-rated vehicles.
The 2.0-liter EcoBoost engine produces 240 horsepower and 270 pound-feet of torque, but more importantly, it allows the SSP sedan to achieve somewhere in the neighborhood of 22 miles per gallon city and 32 mpg highway, which are the civilian 2.0-liter Taurus' official EPA ratings. Ford estimates that the SSP sedan will get 20 mpg city, 30 mpg highway and 23 mpg combined, with the help of Active Grille Shutters that open to allow more cooling air through to the radiator, or close to optimize aerodynamics and fuel economy. Those numbers compare favorably to the discontinued Crown Victoria-based Interceptor's 14 mpg city and 21 mpg highway and the newer Taurus-based cars equipped with V6s, the most fuel efficient of which gets 18 mpg city and 26 mpg highway.
If it was driven 90,000 miles over the course of three years, a 2.0-liter SSP sedan would save law enforcement agencies $5,042.92 versus the Crown Vic, Ford estimates. The EPA is expected to post official fuel-economy numbers for the SSP sedan in December. Until then, read the press release below for more information.

Ford's cars being held up in Chinese ports in trade tensions with U.S.

BEIJING — Ford Motor Co's imported vehicles are being held up at Chinese ports, three people with knowledge of the matter told Reuters, underscoring how U.S. goods are facing increased customs scrutiny in China amid a tense trade standoff. The three people said Ford and Lincoln vehicles were facing unusual delays at customs, with officials asking for extra technical checks. Two of the people said U.S.-made models of some German carmakers, mainly SUVs, being brought into China, were also affected. Ford was being asked to do extra checks on emission components, said a China-based Ford executive familiar with the matter, asking not be named because of the sensitivity of the issue. China's customs agency did not immediately respond to requests for comment. The holdups add to a growing list of American products facing issues at China's borders, as officials try to avert a full-blown trade war. Some trade experts said they believe Beijing is sending a defiant warning to Washington in response to sweeping U.S. trade demands made on China last week. Reuters reported Tuesday that China had ramped up inspections of pork shipped from the United States, after the country's customs agency said it would step up quarantine checks on American apples and logs. The second person, a China-based industry official with knowledge of the matter, said the delays for Ford — as well as some U.S.-made cars from BMW and Mercedes-Benz — had been going on for the last two weeks. "Customs pretends there are technical non-conformities of some nature that won't allow them to clear these U.S.-made cars through customs, but the U.S.-China trade frictions must be the background to this," he said. "Although no one will officially admit it." Responding to a request for comment from Reuters, a BMW spokesman said that "U.S.-made BMW cars have not been delayed at the ports as of last week and before." A Daimler spokeswoman said it was "monitoring the situation closely" regarding ongoing trade talks between China and the United States, but that she could not speculate further on other matters. The third person said the Ford issue, which had been noted by the United States government, and other holdups facing American goods, were clearly related to the trade dispute. A Ford spokeswoman in Shanghai when asked about the matter said: "We are closely monitoring our situation at the port." She declined to comment further.