Ford F250 Xlt Supercab 7.3 Diesel on 2040-cars

Auto blog

Ford, Volvo join Redwood in EV battery recycling push in California

Ford and Volvo will join battery recycling startup Redwood Materials in developing processes, starting in California, to collect end-of-life batteries from electric and hybrid vehicles and recover the materials for use in new batteries, the companies said Thursday. Redwood Materials, co-founded by former Tesla executive JB Straubel, formed an earlier partnership last fall with Ford to develop a “closed loop” or circular supply chain for electric vehicle (EV) batteries, from raw materials to recycling. On Thursday, Redwood Materials said it would work directly with dealers and dismantlers in California to identify and recover end-of-life battery packs. The materials in those packs will be recovered and recycled at Redwood Materials facilities in northern Nevada. U.S. automakers Ford and General Motors Co (GM) have said the battery recycling effort is crucial in efforts to develop a domestic supply chain to meet increasing EV demand. GM and battery partner LG Energy Solution last year announced a partnership with startup Li-Cycle to recycle battery scrap material from Ultium Cells, the GM-LG joint venture that is building battery plants in Ohio, Tennessee and Michigan. Redwood Materials has similar partnerships with battery makers Panasonic in Nevada and Envision AESC in Tennessee, as well as with Amazon. Ford and Amazon are among the investors in Redwood Materials. Reporting by Paul Lienert in Detroit; Editing by Mark Potter Green Ford Volvo Green Automakers Electric

Ford Recalling 70k Escape and Mariner Hybrids for cooling issue

Ford is recalling about 70,209 examples of the 2005-2008 Ford Escape Hybrid and the 2006-2008 Mercury Mariner Hybrid because the cooling pumps for their hybrid systems could fail.
According to the company's defect notice, it's possible for the original "Motor Electronics Coolant (MEC) Pump" to wear out and fail, which would could cause the hybrid system to overheat. If this happens, the vehicle goes into a safety mode that takes away most or all of its power. However, braking and steering still operate normally. After cooling down, the affected models restart normally. The company says that it's not aware of any accidents or injuries related to this problem.
Ford will begin repairing the vehicles in late October, and dealers will be installing improved, brushless pumps on the affected models at no charge to owners. If drivers had their pumps fail before this recall, they can contact Ford for a possible reimbursement. Scroll down to read the recall announcement from the National Highway Traffic Safety Administration or download the full defect notice as a PDF, here.

NHTSA will investigate some Ford Fusion, Lincoln MKZ models for power steering issue

The National Highway Traffic Safety Administration is opening an investigation into the 2010-2012 Ford Fusion, Fusion Hybrid and Lincoln MKZ, the 2012 MKZ Hybrid and 2011 Mercury Milan because the agency has hundreds of complaints of electric power steering failure in these models.
According to NHTSA's data, it has received 508 complaints of the power steering allegedly suddenly malfunctioning and resulting in increased effort to turn the wheel. In four incidents, these failures resulted in loss of control and crashes. According to the reports, in some cases a power steering warning message came on as the fault occurred, and other times the system restored itself by turning off and then restarting the vehicle. NHTSA said it has also received further field report data from Ford, but that information hasn't been publicly released yet.
For the moment, there isn't a recall for this failure on these models. NHTSA is just investigating them to "assess the scope, frequency and safety consequences of the alleged defect," and the agency says an estimated 938,000 vehicles could potentially be affected.