2015 Ford F250 Xl on 2040-cars

Auto blog

NHTSA closes Ford F-Series Super Duty steering probe without recall

The National Highway Traffic Safety Administration's investigation into 2008 Ford F-250 and F-350 Super Duty pickups, which was originally opened last year, has now ended without a recall. NHTSA was looking into steering failures on some 336,000 trucks.
The issue rested with the steering gear - NHTSA received five complaints of failures - which was redesigned in 2005. According to the report on the matter, investigators "found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload."
NHTSA investigators, however, "found no evidence of fatigue or material property defects in any of the fractures. Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns," according to the report, obtained by The Detroit News.

Ford Mustang Mach-E fails Sweden's moose test

The infamous moose test has claimed another casualty. This time it's the Ford Mustang Mach-E AWD Long Range, which was tested in an electric four-way alongside the Tesla Model Y, Hyundai Ioniq 5 and Skoda Enyaq iV (an electric utility vehicle closely related to the Volkswagen ID.4 that is sold in the United States). According to the Swedish testers at Teknikens Varld, Ford's electric car not only failed to hit the speed necessary for a passing grade, it didn't perform well at slower speeds, either. To pass the outlet's moose test, a car has to complete a rapid left-right-straight S-shaped pattern marked by cones at a speed of at least 72 km/h (44.7 miles per hour). The test is designed to mimic the type of avoidance maneuver a driver would have to take in order to avoid hitting something that wandered into the road, which in Sweden may be a moose but could just as easily be a deer or some other member of the animal kingdom elsewhere in the world, or possibly a child or car backing into the motorway. Not only is the maneuver very aggressive, it's also performed with weights belted into each seat and more weight added to the cargo area to hit the vehicle's maximum allowable carrying capacity. The Mustang Mach-E only managed to complete the moose test at 68 km/h (42.3 mph), well below the passing-grade threshold. Even at much lower speeds, Teknikens Varld says the Mach-E (which boasts the highest carrying capacity and was therefore loaded with more weight than the rest of the vehicles tested in this quartet) is "too soft in the chassis" and suffers from "too slow steering." Proving that it is indeed possible to pass the test, the Hyundai and Skoda completed the maneuver at the 44.7-mph figure required for a passing grade and the Tesla did it at 46.6 mph, albeit with less weight in the cargo area. It's not clear whether other versions of the Mustang Mach-E would pass the test. It's also unknown if Ford will make any changes to its chassis tuning or electronic stability control software, as some other automakers have done after a poor performance from Teknikens Varld, to improve its performance in the moose test. Related video:

FCA to pay buyers $1,700 to swap out of scandal-mired VWs

FCA is trying to gain some sales from arch-rival VW in the competitive European market by offering potential buyers in Italy up to $1,700 to swap into an FCA group car. While the promotion isn't specifically targeted at TDI owners affected by the emissions scandal, it is clearly intended to turn dissatisfaction with VW's defeat device cheat into additional sales, Bloomberg reports. The 500-1,500 euro incentive (roughly $560-1,700, depending on vehicle) stacks on top of any other rebates or deals applicable, and applies if a buyer brings in any of Volkswagen Group's cars – including Audi, Skoda, and SEAT, among (many) others. As Bloomberg notes, it's normal for automakers to offer "conquest" deals – giving a buyer cash for trading in a competitor's vehicle. Those deals aren't usually limited to one company's products, however; FCA's program looks specifically to take advantage of VW's legal and public relations nightmare. FCA isn't the only automaker trying this trick in Italy. Automotive News Europe also reported that Ford is offering approximately $840 in incentives across its entire range to owners of VW vehicles seeking to trade in for a Ford. No word of yet as to whether these incentives will spread beyond Italy or to other automakers.Related Video: