1993 Ford Exploer, No Reserve on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

Yearly auto recall record demolished in 6 months

With nearly 40 million vehicles under repair campaigns and counting, 2014 will almost certainly go down as the year of the automotive recall. At just past the halfway mark, we are already at record levels, and there aren't any signs that the epidemic is slowing. General Motors' latest 8.4 million vehicle recall in the US puts the industry over the top for the title of the most cars with fixes pending from automakers ever. That's a prize no one ever wants to receive. According to TheDetroitBureau.com, the US recall total has hit 39.85-million vehicles to surpass the previous record of 33.01 million in 2004. Perhaps more surprising, with over 26 million repairs pending, it's still quite possibly that GM could recall more vehicles by the end of the year than the 27.96-million unit total of the entire US auto industry last year. With over 40 campaigns under its belt in 2014, the roughly one million cars it would take would hardly come as a surprise at this point, especially with increased government scrutiny into the Detroit automaker's processes. The pace of recalls started off relatively normal this year, with just a smattering of campaigns. The most surprising early on was Aston Martin calling in about 75 percent of its output since 2007 due to counterfeit plastic, but with just a few thousand cars, it was relatively tiny in pure numbers. GM really kicked things off soon after, but we didn't know it at the time. It issued its first bulletin for 778,000 Cobalt compacts in early February. Things only ballooned from there as more models were added to its growing ignition switch problem. The onslaught of announcements from every major automaker hasn't abated since then. Some industry executives are trying to put a positive spin on the situation. "With what's transpired (in recent months), there's a higher level of scrutiny," said Joe Hinrichs, Ford president of the Americas, to TheDetroitBureau.com. He believes that automakers are looking at data much more thoroughly than before, and it means better customer safety. Still, many consumers probably wish these problems had been found before their car went on sale.

Recharge Wrap-up: Ford announces e-bike project, Honda Accord Hybrid availability catches up

Supplies of the Honda Accord Hybrid have apparently caught up with demand. Honda originally launched the Accord Hybrid for the 2014 model year, but lack of availability plagued interested customers and eager dealers alike. Honda cited "component supply constraints" - likely batteries, electric motors and the like - for the lack of available vehicles. Now, "The supply of Accord Hybrids in general is in line with the supply of the regular Accord sedan," according to Honda's Angie Nucci. Read more at Green Car Reports. Apple is seeking a resolution to a lawsuit accusing the company of poaching employees from lithium-ion battery maker A123 Systems. A123 has requested a court order stopping a former employer from breaking an employment agreement, as well as keeping Apple from encouraging the person to do so. Apple has requested more time to respond to that court order. A123 has also filed a suit accusing five employees of breaking nondisclosure agreements and going or trying to go to work for Apple. Insiders say that Apple is developing an electric car that could go into production as early as 2020. Read more at Automotive News. South Dakota's Ethanol Infrastructure Incentive Program is helping retailers fund ethanol storage. The state government has set aside $300,000 as part of the program to fund ethanol storage tanks at gas stations. The program, which originally set out to reimburse retailers for building ethanol flex-pumps, is now helping them expand their ethanol capacities. Retailers can apply for funds for pumps and storage through June 30. Read more at Argus Leader. Ford is expanding its Global Mobility Plan with the Handle on Mobility electric bike experiment. The foldable MoDe:Me e-bike is for personal use and commuting, while the MoDe:Pro is built for commercial duty, with both powered by a 200-watt motor and 9-amp-hour battery. The bikes use an iPhone app called MoDe:Link, which provides various information and controls important bike functions. Through the app, the bikes offer navigation (with traffic data, available public transportation and charging locations included), with handlebar vibrations letting the rider know when and where to turn and automatically activating turn signals. The bike can sense and alert the rider to other vehicles on the roadway. Pedal assist is based on heart rate, allowing the rider to arrive at their destination comfortably. See the bikes in the video above, and read more from Ford.