2015 Ford Explorer Limited on 2040-cars

Auto blog

Pickup sales may hit 2M units for first time since 2007

Even as fuel prices creep back up, trucks are still a hot item among new-vehicle shoppers. To see how popular pickup trucks still are, you don't have to look any further than how much effort automakers put into the continual one-upmanship of their trucks. Backing this fact up, USA Today is reporting that the segment could top two million sales this year - a total not matched since 2007, though still far from the pre-recession, three-million-unit levels.
Through August, the Ford F-Series continues to be the segment leader with almost 500,000 units sold, but the Chevy Silverado (328,269), Ram 1500 (234,642), GMC Sierra (122,232) and Toyota Tacoma (110,293) are all seeing at least 20-percent sales increases, helping to account for around 1.44 million truck sales so far this year - not including possible outliers like the Suzuki Equator and Chevy Avalanche.
This year alone, General Motors has completely redesigned its fullsize trucks, Ram and Toyota have significantly updated their offerings, the next-gen Ford F-150 will be out next year and Nissan is promising an all-new Titan around the same time with an eventual Cummins diesel under the hood. It would seem, then, that truck sales are poised to continue their upward trend.

Ford moving medium-duty F-Series production from Mexico to Ohio

A few more Ford trucks will be built in the US in the near future with news that production of the F-650 and F-750 medium-duty trucks will move from Mexico to Ford's Ohio Assembly Plant in Avon Lake, OH. Ford hasn't confirmed a precise timeline for the move, but The Detroit News claims the Blue Oval will make the shift later this year or in early 2015.
As Ford spokesperson Mike Levine reminded us, back in 2011, Ford announced in an investor release that it would shift production "after the [Ohio] plant stops current production of the Ford E-Series vans." According to that release, the Ohio factory will also receive $128 million in upgrades to build the new trucks, plus the F53 motorhome chassis and F59 commercial chassis.

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.