2009 Ford Escape Limited Sport Utility 4-door 2.5l Black/blk Leather on 2040-cars

Auto blog

Ford recalls 434k vehicles for several unrelated issues

It seems that the hard winter in much of the country has been as rough on some Fords as it has on many people. The Blue Oval is recalling roughly 434,000 vehicles in two separate recalls, and one of them partially caused by the salt used to melt the snow on roads.
The first recall covers 385,750 2001-2004 Escape models in the Midwest, Northeast and Canada because a subframe could rust and eventually fail. This is partially due to the road salt used in those areas, and about 349,000 of the affected vehicles are in the US. To remedy the problem, dealers are installing a reinforcement cross brace on the frame to strengthen them. There has been one crash caused by the failure but no injuries. According to The Detroit News, this is not the first rust-related recall for Ford. It estimates the company has repaired over two million vehicles since 2010 for problems on vehicles related to the iron oxide, including the rear wheel wells of the Freestar minivan.
The second recall covers 48,950 2013-2014 Ford Fusion, Escape, C-MAX and Lincoln MKZ models because welds in their seatbacks don't meet National Highway Traffic Safety Administration standards. The fault affects the front seats, and the sub-standard welds joining the setback to the recliner could increase the chance on injury. There have been no reported injuries or accidents caused by the problem, but there are 42,972 affected vehicles in the US and 4,744 in Canada.

Watch Ken Block's scary Rally America crash from inside the cockpit

Ken Block became famous for his series of Gymkhana videos, but he's a real racer in his own right. Block has competed many rounds in the FIA World Rally Championship and also rallied in the 2013 Rally America series. He nearly won that latter title last year - if not for a massive crash in the final event of the season.
Block and his co-driver Alex Gelsomino went into the Lake Superior Performance Rally needing a win to take the championship. However, missing a clump of dirt on the side of the road and one little word in the pace notes was all it took to catapult Block's Fiesta off the road and into a tumbling accident. Block says his initial reaction was anger because the crash came out of nowhere.
For 2014, Block is joining the FIA World Rallycross Championship for at least three rounds. He'll drive a Ford Fiesta for the Hoonigan Racing Division at the Norwegian, French and Turkish events of the 12-round championship. Former Formula One World Champion Jacques Villeneuve will also compete in the series.

NHTSA closes Ford F-Series Super Duty steering probe without recall

The National Highway Traffic Safety Administration's investigation into 2008 Ford F-250 and F-350 Super Duty pickups, which was originally opened last year, has now ended without a recall. NHTSA was looking into steering failures on some 336,000 trucks.
The issue rested with the steering gear - NHTSA received five complaints of failures - which was redesigned in 2005. According to the report on the matter, investigators "found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload."
NHTSA investigators, however, "found no evidence of fatigue or material property defects in any of the fractures. Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns," according to the report, obtained by The Detroit News.