2009 Ford E-350 Super Duty Base Extended Cargo Van 3-door 5.4l on 2040-cars

Auto blog

Ford finds flex-fuel engine design plays big role in emissions output

How bad is ethanol for your engine? There's been a lot of debate on this issue as the US considers upping the biofuel content in the national gasoline supply from 10 percent (E10) to 15 percent (E15). The ethanol industry and some scientists say higher ethanol blends show no "meaningful differences" in new engines while the oil industry says ethanol creates health risks. Researchers working at the Ford Research and Innovation Center decided to take a closer look at how a wide range of gas-ethanol blends - E0, E10, E20, E30, E40, E55 and E80 - affected the emissions coming out of a flex-fuel 2006 Mercury Grand Marquis. To see the full report, printed in the journal Environmental Science & Technology, requires payment, but there is an abstract and Green Car Congress has some more details. The gist is that, "with increasing ethanol content in the fuel, the tailpipe emissions of ethanol, acetaldehyde, formaldehyde, methane, and ammonia increased." At least NOx and NMHC emissions decreased. The researchers say that the effects are due to the fuel and "are expected for all FFVs," but that the way that a manufacturer calibrates the engine will affect NOx, THC, and NMOG emissions. It's this last bit that's important, since the researchers found, "Higher ethanol content in gasoline affects several fundamental fuel properties that can impact emissions. ... These changes can have positive or negative effects that can depend on engine design, hardware, and control strategy. In addition to direct emissions impacts, higher ethanol content fuel can also provide more efficient combustion and overall engine operation under part-load conditions and under knock-limited higher-load conditions." So, as we head towards more ethanol in our fuel supply (maybe), manufacturers are going to need to learn how to burn it most efficiently.

How the Ford F-150 SVT Raptor became a reality

The camouflaged Ford F-150 SVT Raptor prototype captured above blazing its way across the desert during a test run left company engineers giggling in amazement, reveals Jamal Hameedi in a new Autoweek video. Ford's global performance vehicle chief engineer, accompanied by senior exterior designer Bruce Williams, sat down with the publication to discuss the concept and development of the automaker's super off-road F-150.
Designing a high-performance pickup in 2008, right when the cost of gasoline was going through the roof, seemed insane at the time, but the team pushed forward with the innovative vehicle regardless. The interview includes plenty of Ford B-roll footage as visual candy, and the conversations include discussions about exterior design, ride comfort, anti-lock brake tuning, suspension engineering, weight reduction and why it was necessary to make the Raptor visually different than Ford's standard F-150. The model's origin story is very interesting, and you can learn more about it by watching the video below.

An amazing Group B rally car collection heads to auction

Kicking off in 1982, the Group B era spawned some of the most fearsome rally cars of all time. The technologically advanced pioneers of all-wheel drive and turbocharging defined a time when automakers had carte blanche to build machines with unrestricted power, without the burden of homologating a large number of road cars to qualify. The results were sometimes deadly, leading the FIA to ban the class after 1986. Now, a collection of seven Group B monsters is headed across the block in Paris as part of the Artcurial auction, held in partnership with France's famed Retromobile show. The show has been delayed to June, however. There's a 1985 Peugeot 205 Turbo 16, one of 20 Evo II models that helped the company achieve two championships in Group B's short run. This particular example was driven by world champion Timo Salonen at the 1986 Swedish Rally, where it finished seventh due to an oil filter seal failure. Bruno Saby subsequently drove it at the 1986 Tour de Corse and Peugeot entered it at the 1986 Acropolis Rally as well. It's still registered to Peugeot Talbot Sport and represents a French technological achievement, according to Artcurial, comparable to the Concorde or TGV train. Representing Italy are a pair of Lancias in the iconic Martini livery. The Lancia 037 helped Bel Paese clinch its only Group B victory in 1983, after a hard-fought rivalry with Audi. It's one of the few Group B cars that weren't AWD, achieving its success the old-fashioned way, through lightness and superb handling. A second Lancia, a 1986 Delta S4, was the culmination of the Italian firm's later Group B efforts and one of Saby's favorites. While Group B was no more in 1987, the S4 was the predecessor to the Delta Integrale that would dominate WRC from 1987 through 1992. While the collection also includes greats like a Ford RS200, Renault 5 Maxi Turbo, and MG Metro 6R4, the centerpiece is the Audi Quattro Sport S1. The ultimate Group B machine, it introduced all-wheel-drive and turbocharging to the sport. It also employed the wildest use of wings and air dams to generate downforce. Tunable up to 590 horsepower, it could rocket to 60 mph in about three seconds. The car offered for sale came straight from Ingolstadt, a 1988 model built for the Race of Champions of ex-Group B cars. The collection was amassed in the late 80s and early 90s, not long after Group B's dissolution.