2014 Chrysler Town & Country Touring-l on 2040-cars

Auto blog

Chrysler says its 8-speed transmissions will save 700 million gallons

Chrysler Group's TorqueFlite eight-speed transmission could be earning some serious green bragging rights if the company's projections are correct. The recently widely proliferated automatic gearbox, which is now in more than a million vehicles around the world, is poised to save drivers an estimated 700+ million gallons of fuel over the vehicles' lifetimes (an expected cost savings of $2.5 billion). In addition, Chrysler expects a reduction in CO2 emissions by more than six million metric tons. According to Chrysler, and depending on the vehicle, the TorqueFlite can improve fuel economy. The TorqueFlite autobox features particularly close ratios from fifth to eighth gear (see the press release below for the specific numbers), and uses low-viscosity fluid that doesn't need to be replaced. Transmission software adapts to the driving situation to optimize efficiency based on driver behavior, temperature, grade, stability control, and longitudinal and lateral acceleration. The TorqueFlite is capable of handling a variety of duties. As evidenced by the wide range of vehicles Chrysler Group has seen fit to equip with the eight-speed transmission, the TorqueFlite is capable of handling a variety of duties. Since its 2012 introduction, the TorqueFlite has gone from performing cog-swapping duties in Dodge Charger and Chrysler 300 models equipped with the 3.6-liter Pentastar V6 to changing gears in vehicles such as the Pentastar- and Hemi-powered Dodge Durango, Jeep Grand Cherokee and even the Ram 1500 EcoDiesel. For the 2015 model year, the eight-speed is finding its way into even more vehicles with the addition of a third version. In addition to the American-made TorqueFlite 845RE and 8HP70, the new 8HP90 will be manufactured in Saarbrucken, Germany. The 8HP90 is designed for higher torque loads, making it ideal for high-performance vehicles like the 2015 Dodge Challenger SRT Hellcat. The already-in-use 8HP70 will expand its duties to be used in 2015 Hemi models such as the Dodge Charger, Challenger, and Challenger SRT8. You can see the list of those benchmarks in Chrysler's press release below.

Are old airbags killers?

Takata airbags may not be the only ones with some very serious problems. A new report from TheDetroitBureau.com claims that the National Highway Traffic Safety Administration has opened its second investigation into bad airbag inflators, and this time, they aren't from Takata. The focus of this latest case is on the airbag inflators in some 500,000 older Chrysler Town and Country minivans and Kia Optima sedans, all of which come from ARC Automotive. While the Takata case looks at problems stemming from the engineering and production process, the ARC investigation focuses on the age of the inflators. As TDB explains, airbag inflators are essentially what the military refers to as shaped charges, sort of like Claymores (for fans of the Call of Duty series). In combat, they blow up in a specific direction, protecting those behind the explosion, although in the case of airbags, the explosion "[creates] a precise rush of hot gases" that inflate the bags. NHTSA's worry is that with the increased average age of today's vehicles, years and years of being bounced, jolted, and shaken about and exposed to often-radical temperature changes have altered the nature of the explosives in these vehicles, causing too big of an explosion. "It may be a reasonable assumption that as these things age they deteriorate." – Analyst George Peterson "It may be a reasonable assumption that as these things age they deteriorate," analyst George Peterson told TheDetroitBureau.com. NHTSA boss Mark Rosekind backed up aging angle. "Cars are lasting on the road a lot longer than ever before," Rosekind told TDB, adding that seals could start breaking down. "Is aging now an issue? That's part of the investigation going on." NHTSA has only identified two "incidents" so far, although according to Center for Auto Safety Director Clarence Ditlow, there's genuine concern that there could be additional unidentified cases. "Could we have missed more? That could be the case," Ditlow told TDB, citing the misidentified deaths in the Takata investigation. Ditlow was quick to point out that, even in older vehicles, airbags are much more likely to protect than harm. "No one is saying you should disable your airbags," the safety advocate told TDB. "You're far more likely to be helped than hurt by one if they go off." At least one automaker, meanwhile, has already been advised of the investigation by NHTSA and is checking its airbags.

The USPS needs 180,000 new delivery vehicles, automakers gearing up to bid

Winning the New York City Taxi of Tomorrow tender was a huge prize for Nissan, even though the company is still working through the process of claiming its prize. The United States Postal Service has begun the process to take bids for a new delivery vehicle to replace the all-too-familiar Grumman Long Life Vehicle, and that will be a much larger plum for the automaker who wins it, perhaps worth more than six billion dollars. The Grumman LLV is an aluminum body covering a Chevrolet S-10 pickup chassis and General Motors' Iron Duke four-cylinder engine. The USPS bought them from 1987 to 1994, and the 163,000 of them still in service are a monumental drain on postal resources: they get roughly ten miles to the gallon instead of the quoted 16 mpg, drink up more than $530 million in fuel each year, and their constant repair needs like the balky sliding door and leaky windshields have led the service to increase the annual maintenance budget from $100 million to $500 million. A seat belt is about as modern as it gets for safety technology, and the USPS says that assuming things stay the same, it can't afford to run them beyond 2017. Last year it put out two triage requests for proposals seeking 10,000 new chassis and drivetrains for the Grumman and 10,000 new vehicles. The LLV is also too small for the modern mail system in which package delivery is growing and letter delivery is declining. The service says it doesn't have a fixed idea of the ideal "next-generation delivery vehicles," but it listed a number of requirements in its initial request and is open to any proposal. Carriers have some suggestions, though, saying they want better cupholders, sun visors that they can stuff letters behind, a driver's compartment free of slits that can swallow mail, and a backup camera. The request for information sent to automakers pegs the tender at 180,000 vehicles that would cost between $25,000 and $35,000 apiece, and it will hold a conference on February 18 to answer questions about the contract. GM is the only domestic maker to avow an interest, while Ford and Fiat-Chrysler have remained cagey. Yet with a possible $6.3 billion up for grabs and some new vans for sale that would be advertised on every block in the country, we have a feeling everyone will be listening closely come February 18. We also have a feeling the LeMons series is going to be flooded with Grummans come 2017. News Source: Wall Street Journal, Automotive News - sub.