2005 Chrysler Town on 2040-cars

Auto blog

Chrysler recalling 780k minivans over fire risk

Chrysler is recalling 780,000 of its Town & Country and Dodge Grand Caravan minivans from the 2010 to 2014 model years due to the possibility of circuits overheating, which can lead to a fire. Of the 780,000 total vans being recalled, Chrysler estimates that 644,850 are in the US, 106,980 are in Canada, 8,009 are in Mexico, and 20,638 are in other markets. All of the affected vehicles were built between August 25, 2010 and October 31, 2013.
Chrysler's engineers discovered that beverage spills or exposure to moisture (from rain, snow, car washes, and the like) were linked to circuits shorting in the window switch assembly. Short circuits can overheat, and thus, cause a fire.
Chrysler will contact owners and let them know when they may schedule service, at which point, the window switches will be replaced. In the interim, the automaker says that owners may visit their dealers after May 14 to have the switches disconnected.

Chrysler extends fuel tank warranties on LX cars, NHTSA ends probe

The National Highway Traffic Safety Administration has ended its investigation of 153,817, 5.7-liter and 6.1-liter Hemi V8-powered 2006 Chrysler 300, Dodge Charger and Dodge Magnum models after reports of stalling. Chrysler has responded by granting a lifetime warranty on the fuel tanks for these vehicles.
NHTSA received 299 reports of engines stalling while the models were stopped or driving at low speeds, and began an investigation. The government agency found that the control valve shutoff float in the V8s' 19-gallon fuel tank could malfunction if the fuel had too high of an ethanol content. In many cases, the valve would break in the open position, allowing the tank to be overfilled, which would then cause the cars to stall. However, there were no accidents reported, and the vehicles could be restarted immediately.
There will not be a recall on these vehicles because, "the condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty," NHTSA said to The Detroit News.

Jeep Begins Fixing 1.56 Million Recalled Grand Cherokee, Liberty SUVs

Chrysler is just now beginning the big job of fixing 1.56 million older Jeep SUVs seven months after a recall was announced, according to The Detroit News. Jeep Grand Cherokees sold between 1992 and 1998 and Jeep Liberty models sold between 2002 and 2007 are being recalled because the gas tank can leak in the event of a rear-end collision, leading to a fire. The National Highway Traffic Safety Administration originally requested the recall of 2.7 million vehicles. Chrysler initially disputed NHTSA's findings and seemed willing to go through a court battle until an 11th-hour deal reduced the number of vehicles involved in the recall. The remaining vehicle owners left out of the recall will receive a "customer service action" notification and may not get fixed. Chrysler says the vehicles are safe and need no repairs. Fixing the 1.56 million Jeeps will cost Chrysler $151 million. NHTSA cited 51 deaths causes by such tank fires. Chrysler plans to install protective trailer hitches to protect the gas tanks, but even the automaker admits the hitches will only provide incremental protection in a low-to-moderate speed rear-end crash. Related Gallery 2014 Jeep Cherokee Test Drive View 9 Photos Recalls Chrysler Jeep jeep liberty