2006 Chrysler 300 C Sedan 4-door 5.7l on 2040-cars

Auto blog

Marchionne says Fiat Chrysler can make 6 million cars per year

The combined Fiat Chrysler Automobiles will see its production capacity increase from a projected 4.6 million in 2014 to 6 million units once it completes its integration, according to statements made by FCA CEO Sergio Marchionne.
"With the initiatives we will announce in May, six million is accessible," Marchionne said during a Fiat shareholders' meeting in Turin, according to The Detroit News. Marchionne is aiming to complete the merger between the Turin, Italy-based Fiat and the Auburn Hills, MI-based Chrysler by the end of this year.
Increasing production by 1.4 million units is no small order, particularly when combined Fiat and Chrysler sales have increased only modestly in the past few years - only 4.4 million units were sold in 2013, and while 4.6 million is projected for 2014, 4.5 million is also a distinct possibility. Six million units per year has been Marchionne's self-imposed goal for the combined automaker, according to The News, claiming that FCA would need to crest that point to achieve profitability.

Chrysler extends fuel tank warranties on LX cars, NHTSA ends probe

The National Highway Traffic Safety Administration has ended its investigation of 153,817, 5.7-liter and 6.1-liter Hemi V8-powered 2006 Chrysler 300, Dodge Charger and Dodge Magnum models after reports of stalling. Chrysler has responded by granting a lifetime warranty on the fuel tanks for these vehicles.
NHTSA received 299 reports of engines stalling while the models were stopped or driving at low speeds, and began an investigation. The government agency found that the control valve shutoff float in the V8s' 19-gallon fuel tank could malfunction if the fuel had too high of an ethanol content. In many cases, the valve would break in the open position, allowing the tank to be overfilled, which would then cause the cars to stall. However, there were no accidents reported, and the vehicles could be restarted immediately.
There will not be a recall on these vehicles because, "the condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty," NHTSA said to The Detroit News.

NHTSA investigating power modules on Chrysler Group SUVs and minivans

The Center for Auto Safety is officially petitioning the National Highway Traffic Safety Administration to begin scrutinizing alleged problems with the totally integrated power module (TIPM) on about 24 Chrysler Group SUVs and minivans. The advocacy group claims that the part's failure can cause affected vehicles to stall or not start at all. NHTSA is still looking into the accusations and deciding whether a full investigation is actually warranted.
The CAS petition claims at least 70 TIPM failures, but according to NHTSA, six of the complaints are for models that don't have the modules. In 34 of the reported cases, the vehicles refused to start, and in 17 of them the engine stalled. There were also two allegations of smoke and one of a fire. However, none of these affected airbag deployment or resulted in a crash.
This petition isn't the first TIPM-related problem for Chrysler Group. A recent report in the New York Times alleged that it found 240 complaints potentially related to the issue on NHTSA's website alone. In September, the automaker also recalled 230,760 examples worldwide (188,723 in the US) of the 2011 Jeep Grand Cherokee and Dodge Durango replace the fuel pump relay circuit inside of the TIPM-7 with one external to the unit. The original part could allegedly cause the models to stall without warning. Even earlier, the company also recalled about 80,000 examples of the Jeep Wrangler and Dodge Nitro in 2007 to have the module reprogrammed.