2014 Chevrolet Volt Base on 2040-cars

Auto blog

GM recalls 3.8 million vehicles in North America due to braking issue

WASHINGTON — General Motors Co said Wednesday it was recalling 3.46 million U.S. pickup trucks and SUVs to address a vacuum pump issue that could make braking more difficult and that has been linked to 113 accidents and 13 injuries. The recall covers 2014-2018 model year vehicles, including some Cadillac Escalade, Chevrolet Silverado, Chevrolet Tahoe, GMC Sierra, Chevrolet Suburban and GMC Yukon vehicles. In late June, GM recalled 310,000 vehicles in Canada for the same issue. GM did not immediately explain why the Canadian recall occurred more than two months before it called back the vehicles in the United States. The recall was triggered because the amount of vacuum created by the vacuum pump may decrease over time, GM told the National Highway Traffic Safety Administration (NHTSA) in documents posted on Wednesday. The NHTSA opened a preliminary investigation into the issue last November, and said it had reports of nine related crashes and two injuries. It provided GM in July with additional field reports that prompted the automaker to open an investigation. GM said it could affect braking in "rare circumstances." The NHTSA said in a statement the "vehicles may experience brake boost failure, which would require increased brake pedal effort, leading to a hard brake pedal feel, and potentially increased stopping distance." GM said dealers will reprogram the electronic brake control module to improve how the system utilizes the hydraulic brake boost assist function when vacuum assist is depleted. GM said the vacuum assist pump, which is lubricated with engine oil that flows into the pump through a filter screen, can in some cases lose effectiveness over time, as debris such as oil sludge can accumulate on the filter screen. GM told NHTSA that prior model years used a different brake assist system design, and vehicles manufactured after 2018 were not equipped with the affected pump design. Separately, GM said on Wednesday it is recalling 270,000 additional U.S. vehicles in three smaller recalls, including 177,000 2018 Chevrolet Malibu cars with 1.5L turbo engines because an error in the engine control module software may result in the fuel injectors being disabled.

GM faces possible class action lawsuit over 8-speed transmission

General Motors has been hit with a class-action lawsuit from owners who allege the eight-speed automatic transmission found in several rear-wheel-drive Chevrolet, Cadillac and GMC models between the 2015 and 2019 model years has a defect that causes the vehicles to hesitate and jerk when accelerating or slowing down. The lawsuit was posted to ClassAction.org and spotted by GM Authority. Problems with GM's Hydra-Matic 8L90 and 8L45 transmissions have been well-documented on Internet forums and via complaints filed with the National Highway Traffic Safety Administration, with many reporting damage to their vehicles. The lawsuit was first filed in December in U.S. District Court for the Southern District of Florida but appears to have been transferred recently to New York. Autoblog sought comment from Theodore Leopold, the lead attorney for the plaintiffs. "These transmissions have a common defect," the complaint reads. "Drivers attempting to accelerate or decelerate their cars feel a hesitation, followed by a significant shake, shudder, jerk, clunk, or 'hard shift' when the vehicle's automatic transmission changes gears." The problem also occurs when the vehicles accelerate in a single gear, without shifting, the plaintiffs allege. "Drivers have reported that the shift is sometimes so violent, they feel as though they have been hit by another vehicle." The problem is believed to center on the transmission, torque converter or both. The complaint says it causes undue friction, causing hydraulic systems and gears to function improperly and sometimes leaves metal shavings throughout the transmission, leading to costly repairs and replacement of parts or the entire transmission. It says GM has known about the problems since shortly after it introduced the transmissions, and has issued 13 technical service bulletins, none of which have resolved the problem. GM declined to comment on the lawsuit. The plaintiffs say GM should have warned consumers about the issues and covered repairs under each vehicle's three-year/36,000-mile bumper-to-bumper warranty. They're seeking statewide classes in at least six states: California, Florida, Illinois, New York, Oklahoma and Texas.

Recharge Wrap-Up: LAPD gets Zero MMX, Chevy's new inverter, Hyundai Tucson's new powertrains

Some police in Los Angeles will be riding Zero MMX electric motorcycles on duty. The LAPD is adding the fully electric police/military all-terrain bikes to its patrol fleet. According to Officer Steve Carbajal of the department's off-road unit, "It costs less than 50 cents to charge compared to using gallons of gas, maintenance is simple, and the community appreciates how quiet they are." The electric bikes, with their lack of noise and a headlight the rider can turn off, also have the benefit of stealth, giving the officers what Carbajal calls "an added tactical advantage." The MMX also has swappable batteries, is designed for quick ignition and has power reserve capabilities so the rider won't be caught with a dead battery while chasing down a perp. Read more at Ride Apart. Remember when it seemed like we'd never run out of oil, and giving your buddy five bucks for gas was actually a worthwhile gesture? Drivers of classic cars in Detroit were able to fill up their tanks at gas prices corresponding to their model year, thanks to a promotion by Hagerty Insurance for National Collector Car Appreciation Day on July 11. That meant prices from 21 to 90 cents a gallon, as the cars that showed up ranged from the years 1929 to 1989. That's about as affordable as charging your EV. Head over to Autoweek for more details and some photos from the event. The next-generation Chevrolet Volt will likely benefit from a new inverter being developed by General Motors. GM is about two-thirds of the way through the development of the new inverter, which should be ready in January 2016. The inverter, which has a peak output of 55 kilowatts a continuous output of 33 kilowatts, will be adaptable for use in other GM vehicles. Chevrolet is working to reduce the Volt's production costs by $10,000 per vehicle, which should make it more affordable, and the new inverter could help reach that goal should it make its way into the car. Read more at Green Car Reports. Hyundai is likely planning some interesting powertrain changes for the 2016 Tucson, says Green Car Reports. Plug-in hybrid? Maybe. Diesel? Probably not. "We are covering the waterfront on all alternative fuel strategies, from standard hybrid, to plug-in, battery-electric, and fuel cell," says Hyundai's US Chief Dave Zuchowski.