2003 Chevrolet Tahoe Z71 Sport Utility 4-door 5.3l on 2040-cars

Auto blog

Next-gen Chevy Silverado and GMC Sierra may use carbon fiber

It's been generally accepted that the next generation of full-size GM trucks will use some sort of strong, lightweight material for the beds while retaining steel for the cab. While aluminum seems like the most obvious choice, according to Automotive News, the Chevy Silverado and GMC Sierra will incorporate both aluminum and carbon fiber in their beds. The publication cites sources from within GM, though it seems the introduction of this comparatively exotic material mix is still a few years off. While carbon fiber is both stronger and lighter than steel and aluminum, it takes significantly more time and money to produce, essentially relegating the material to small-volume cars. The main benefit for trucks is the resulting reduction in weight to improve fuel economy without sacrificing the tough, rugged capabilities truck buyers expect. The Ford F-150 made the switch to aluminum for the 2015 model year and it's proved highly successful. It seemed like it was only a matter of time before the competition followed suit. Automotive News says that the next-gen trucks will launch with aluminum beds and that it will take a couple of years before we'll see any carbon fiber incorporated into the design. Even then, only look for the composite material on higher-trim models, with a trickle down to lower-spec trucks possible further in the future. In 2011, GM announced it was working with Japan-based Teijin Limited on a carbon fiber reinforced thermoplastic. There's a good chance that material's introduction will be on trucks. Related Video: News Source: Automotive News Plants/Manufacturing Rumormill Chevrolet GM GMC Truck

The Tesla Model S was the best-selling EV of 2015

According to numbers crunched over at Hybrid Cars, the Tesla Model S was the best selling pure electric vehicle last year with 50,366 deliveries. These numbers might not tell the whole story, since Tesla reports deliveries made in 2015 that might have been sold in a different calendar year, while other makers are tallying sales. However, it's inarguable that the Model S ended up in more worldwide driveways than the second-place Nissan Leaf, which did about 43,000 sales. In the US alone, Leaf sales were down 42.8 percent year-on-year, from 30,200 in 2014 to 17,269 last year, and that decline also increased throughout the year. That marks a great finish to a great start to 2015, when Tesla took the lead in EV sales in the US for the first quarter. On top of that, as of last year the Model S becomes the second-best selling EV ever, with 107,148 deliveries since the middle of 2012. It trails the Nissan Leaf, with well over 200,000 worldwide sales. The Chevrolet Volt/Opel Ampera combo takes a close third, with about 106,000 sales. The Nissan and Chevy rivals both launched at the end of 2010, a 16-month head start on the Tesla. Down the charts, the Mitsubishi Outlander PHEV which continues to be forbidden fruit for our market notched 39,000 sales. The BYD Qin PHEV sold 31,898 examples in China, and BYD would take the overall victory from Tesla with 58,728 deliveries if you counted all of its EV and PHEV production, such as its electric buses. The BMW i3 nabbed fourth place with 24,057 global sales. In 2011 the Munich automaker said it wanted to sell 30,000 i3s annually by 2014, but by the time the car launched the company considered 15,000 annual sales 'great for now,' so the 2015 number seems a fine place to wind up. Related Video: News Source: Hybrid Cars Green BMW Chevrolet Mitsubishi Nissan Tesla

Mysterious white powder discovered at GM Orion Assembly

Workers at General Motors Orion Assembly Plant in Orion Township, MI uncovered a mysterious white powder in two different parts of the factory earlier this week, raising concerns about worker safety. "We can confirm that an unknown substance (white powder) was found on the floor outside of Gate 6 at Orion Assembly on Monday, August 29. On Tuesday, August 30, we had a second report of a bottle containing a similar substance found inside the plant," GM spokesperson Dayna Hart told The Oakland Press via email. GM stressed that incident didn't disrupt operations at the plant, and that the company was taking steps to ensure the safety of the sprawling factory's workers. That did include, an anonymous worker told The Oakland Press, closing off parts of the factory for two full days, as drug-sniffing dogs and crews in haz-mat suits descended on the area. "A sample of the substance has been sent to a laboratory for identification and results are expected later this week," Hart said. "All findings and actions have been shared with our employees." Orion Assembly currently builds the Chevrolet Sonic and Buick Verano, and will eventually be responsible for production of the new, all-electric Chevy Bolt early next year. Related Video: