4x4,cloth Interior,side Steps,steering Wheel Audio Controls,tow Package on 2040-cars

Auto blog

Chevy Volt 'acceptable,' Nissan Leaf 'poor' in new IIHS safety tests

Ford C-Max Hybrid also scored "acceptable" rating. With US Nissan Leaf sales up almost 30 percent during the first half of the year, the only thing that might be able to stop the battery-electric vehicle is a good, stiff barrier. Unfortunately, thing's aren't always pretty when that happens in the real world, according to new tests from the Insurance Institute for Highway Safety (IIHS). Things with the Chevrolet Volt extended-range plug-in are a little bit rosier, though. The two plug-in vehicles were part of a batch of a dozen vehicles that just went through the IIHS's "small overlap" test, in which the driver's side front corner of the vehicle is crashed into a rigid barrier at 40 miles per hour. Out of the dozen, only the Mini Cooper Countryman was given a "good" rating. Five vehicles, including the Volt and the Ford C-Max Hybrid, were rated "acceptable," two were "marginal" and two, including the Leaf, were "poor." Plug-in vehicles are unique in the crash-test context because of their relatively large battery sizes. In the Volt's case, the driver had a "low risk" of injury, said the IIHS. But the Leaf's crash substantially pushed back the instrument panel and steering column, creating a scenario where the driver was "likely" to sustain leg injuries. The batteries in both the Leaf and the Volt passed safety tests specifically targeted at things like thermo and electrical properties and overall integrity. "Nissan is proud of the Leaf's 'Good' rating in all other IIHS tests, a 4-star NCAP rating from NHTSA and its IIHS Top Safety Pick rating in all previous years since the car's release," the company said in an e-mail sent to AutoblogGreen. "As for the performance of the 2014 Leaf in the 'small overlap frontal test,' Nissan will continue to review these and other results from the IIHS 'small overlap frontal test' as we seek opportunities for improvement." Check out the IIHS's press release and small car crash-test video footage below. Range of ratings: Small car ratings run the gamut in challenging small overlap front test The Mini Cooper Countryman is the only small car to earn a good rating among the latest group of 12 cars subjected to the Institute's small overlap front crash test. Two electric models and a hybrid also are in the mix, with varied results. The electric-powered Chevrolet Volt (with a gasoline engine "range extender") earns an acceptable rating, while its battery-electric rival, the Nissan Leaf, earns a poor rating.

How GM engineers are using diaper 'snow' to keep you warm

Testing how snow affects General Motors' vehicles isn't really a problem right now for the company's engineers, but in the dog days of summer the process isn't exactly easy. The only real option is for them to book time at the automaker's climatic wind tunnel. However, a flash of brilliance from an engineer allows snow to be simulated regardless of the temperature outside, and the discovery is all because of his daughter's wet diaper. The realization came to GM Thermal Systems engineer Nicholas Jahn while he was swimming with his daughter and noticed how her diaper ballooned in size in the water. He found out the substance that makes this possible is called sodium polyacrylate. When the material gets wet it grows and forms fluffy flakes that are a close imitation of snow. Best of all, the stuff can be prepared easily any time of the year, and it's reusable. The engineering team uses the material to test the effectiveness of the heating systems of GM's vehicles. They spread the sodium polyacrylate over the inlets at the base of the windshield to obstruct the airflow and then crank the heater. After some time, they can see how much is being sucked into the system and design more efficient systems in the future. See how the process works in the video above and read about the diaper discovery in GM's press release below. Diapers Change Chevy Cruze Winter Warm-up Time GM validation engineer uses diaper material "snow" to reduce frigid drives 2015-01-06 DETROIT – An item commonly found on an infant's changing table is helping General Motors' engineers simulate snow year round, ensuring heating systems in cars like the 2015 Chevrolet Cruze can quickly and efficiently warm its interior. Packed snow can prevent air from entering the inlet panel at the bottom of the windshield, obstructing the flow of air into the heating system and reducing the amount of air it can push out. This can lead to less efficient warming of the car's interior and windshield defrosting. "The last thing anyone wants to do when it's freezing cold out is scrape their windshield," said Nicholas Jahn, GM Vehicle Thermal Systems engineer. "The testing we perform on the Chevrolet Cruze with the diaper material allows us to maximize the car's heating capabilities." Ironically, Jahn stumbled upon his diaper-based testing method in the middle of summer. During a swim with his daughter, he noticed her diaper multiplied in size when it came into contact with water.

Former Fisker CEO has some advice for Tesla Motors

Former Fisker Automotive CEO and ex-Chevrolet Volt vehicle-line director Tony Posawatz has some words of caution for Tesla Motors. The long-time automaker executive questions the California automaker's long-term viability – and gives some praise – in a talk with Benzinga, which you can listen to below. While the all-wheel-drive D that Tesla unveiled earlier this month in Southern California wowed a packed crowd, Posawatz (starting at around minute 4:45 in the interview) says Tesla would've been better off taking the resources it expended toward that Model S upgrade and directed them towards speeding up the development of a more affordable plug-in. Perhaps a number of investors agreed, since the company's stock fell the day after the D was announced. Posawatz says Tesla has been over-reliant on the sale of ZEV credits. Posawatz also says that Tesla has been over-reliant on the sale of zero-emissions vehicle credits in California for its earnings and questions whether the automaker will ever work at a large enough scale to sufficiently drive down costs and make consistent profits. Tesla CEO Elon Musk would take issue with this characterization. Posawatz first made his mark in the plug-in vehicle world when he was the vehicle-line director at General Motors for the Volt extended-range plug-in from 2006 to 2012. Later that year, he joined extended-range plug-in maker Fisker Automotive as its CEO, though quit that job during the summer of 2013 as the company was descending into insolvency. He joined the Electrification Coalition this past March. News Source: Benzinga Green Chevrolet Fisker Tesla Electric PHEV Tony Posawatz