2022 Chevrolet Silverado 1500 on 2040-cars

Auto blog

GM Recalling Another 2.7 Million Vehicles In Five Separate Campaigns

The recalls keep rolling in from General Motors, evidently keen to avoid repeating the mistakes of the ignition-switch debacle and clean house. This time they're all coming at once, with five separate recalls announced together covering approximately 2.7 million vehicles. The largest of the five actions involves over 2.4 million units of the previous-generation Chevrolet Malibu and Malibu Maxx, Pontiac G6 and Saturn Aura in order to fix brake light wiring harness, which have been found to be susceptible to corrosion. The recall is separate from the 56k Aura sedans which GM recently recalled over faulty shift cables, not to mention the previous massive recall of 1.3 million vehicles – some of them the same models – but appears to have resulted from the National Highway Traffic Safety Administration investigation that started with the G6 almost a year ago. The second-largest campaign involves the 2014 Chevy Malibu, specifically those fitted with GM's 2.5-liter engine and stop/start system, approximately 140,000 examples of which has been found to have problematic brakes. The issue does not appear to be connected to the recall of 8k Malibu and Buick LaCrosse sedans (also involving brake woes) which we reported upon last week. Four crashes have been reported in such models, but GM admits it's not yet clear if the problem was a contributing factor in the accidents. A further 112k Corvette models from the 2005-2007 model years are being called in for problems with their low-beam headlamps resulting from a flexing relay control circuit wire that's not meant to bend. GM says it is "aware of several hundred complaints" about this issue, but notes that there have been no reports of related accidents. In addition, over 19k examples of Cadillac CTS from the 2013 and 2014 model years are being recalled over windshield wipers that might not work after a jump start. Finally, GM is also bringing in 477 examples of its 2014 Chevy Silverado, Tahoe and GMC Sierra (though not the Yukon) to fix a problem with a tie rod in its steering rack. As ever, all recall repairs will be performed free of charge, and GM is now estimating that recall-related actions this quarter will result in an estimated $200-million charge against its second-quarter earnings. Read the full announcement from GM below for further details.

Next-gen Chevy Silverado and GMC Sierra may use carbon fiber

It's been generally accepted that the next generation of full-size GM trucks will use some sort of strong, lightweight material for the beds while retaining steel for the cab. While aluminum seems like the most obvious choice, according to Automotive News, the Chevy Silverado and GMC Sierra will incorporate both aluminum and carbon fiber in their beds. The publication cites sources from within GM, though it seems the introduction of this comparatively exotic material mix is still a few years off. While carbon fiber is both stronger and lighter than steel and aluminum, it takes significantly more time and money to produce, essentially relegating the material to small-volume cars. The main benefit for trucks is the resulting reduction in weight to improve fuel economy without sacrificing the tough, rugged capabilities truck buyers expect. The Ford F-150 made the switch to aluminum for the 2015 model year and it's proved highly successful. It seemed like it was only a matter of time before the competition followed suit. Automotive News says that the next-gen trucks will launch with aluminum beds and that it will take a couple of years before we'll see any carbon fiber incorporated into the design. Even then, only look for the composite material on higher-trim models, with a trickle down to lower-spec trucks possible further in the future. In 2011, GM announced it was working with Japan-based Teijin Limited on a carbon fiber reinforced thermoplastic. There's a good chance that material's introduction will be on trucks. Related Video: News Source: Automotive News Plants/Manufacturing Rumormill Chevrolet GM GMC Truck

Deep discounts — $12K, $13K, $16K — are fueling a pickup price war

Heavy discounts of up to $16,000 per vehicle are fueling a "truck war" among full-size pickups sold in the United States by the Detroit Three, a Reuters analysis shows. Strong U.S. sales this year of the highly profitable big trucks have helped offset lagging passenger car sales. But it is not clear how much of the truck demand is linked directly to ample factory incentives and dealer discounts, or how far sales might decline without those subsidies. A Reuters survey of Ford, General Motors Co's Chevrolet and Fiat Chrysler Automobiles's Ram truck dealers across the United States indicates stores are offering deep discounts the country's bestselling full-size pickup trucks. "The walls are not crashing down on full-size trucks," said Sam Fiorani, vice president of global vehicle forecasting at AutoForecast Solutions in Chester Springs, Pennsylvania. Detroit-based automakers want to keep cranking out their high-margin trucks, he added, and "giving up a little of the profit is the cheapest way to do it." Stores are offering discounts of up to $12,000 on the 2018 Ford F-150, which remains the best-selling vehicle in the country, recording more than 80,000 sales in May. Discounts run up to $13,000 on the 2018 Chevrolet Silverado and as high as $16,000 on the Ram 1500. Average transaction prices for full-size pick-ups range from around $42,000 to $45,000, industry analysts and automakers say. All three companies are spending furiously - GM and Fiat Chrysler to help sell off carryover 2018 trucks to prepare for redesigned 2019 models, and Ford to sustain its long-held sales crown. A supplier fire that temporarily shut down production of the F-150 last month "changed the game," said Jeff Schuster, senior vice president of forecasting at LMC Automotive in Troy, Michigan said. The supply halt nudged Ford's crosstown rivals "to ratchet up incentives on the current models to go after weakness at Ford," he said. Deals advertised on the companies' official websites range from rebates and low-interest loans to ultra-cheap lease rates, but they are not telling the whole story. Ford, for instance, advertises a $2,000 rebate and a $500 financing credit on sales of certain F-150 models. But James Collins Ford in Louisville, Kentucky, is offering discounts of up to $12,215 on the 2018 F-150 XLT SuperCrew 4x4. The price cuts are even steeper at a number of GM and Fiat Chrysler dealers. Quirk Chevrolet is selling the 2018 Silverado 1500 Double Cab at $13,000 off sticker.