1978 Chevrolet Monte Carlo Sport Coupe 2 Door on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Recharge Wrap-up: Chevy Spark EV in Canada, Audi to use Valeo electric supercharger

The Chevrolet Spark EV will become available to retail customers in Canada. "We're expanding our electric vehicle offerings to our customers by offering the 2016 Spark EV for retail sales in the growing EV markets here in Quebec as well as in Ontario and BC," says Chevrolet's Chris Hay. Chevrolet has not yet released pricing for the Spark EV in Canada. In the US, the Spark EV is available in California, Oregon and Maryland. Read more at Hybrid Cars. Four recreational vehicle companies in Texas have settled with the EPA over illegal import and sale of off-road vehicles. The 4,000-plus Hammerhead brand vehicles in question were imported without the proper certification, a violation of the Clean Air Act. Some vehicles lacked proper emission control equipment or were manufactured by a company not listed on the certificate application. The settlement totals $560,000 in civil penalties for the companies involved. Read more from the EPA. The Iowa Supreme Court has upheld the state's natural gas tax, which was challenged by the ethanol industry. Ethanol producers, which use natural gas to make ethanol, argued the complicated tax was unconstitutional, as it forced certain plants to pay more than their competitors. Taxes vary by location, and some plants have to tap into interstate pipelines at much higher tax rates rather than get it from a local utility. Now, ethanol producers will work to change the law. "My hope is that people understand that, something may be constitutional but that doesn't make it good public policy," says Iowa Renewable Fuels Association Executive Director Monte Shaw. Read more at Manufacturing.Net. Audi will use Valeo's electric superchargers to improve fuel economy and acceleration. Valeo says Audi will launch a vehicle using its electric supercharger next year, with other reports suggesting that car will be the Audi Q7. The company says other unspecified automakers will also use the technology in their vehicles. While the electric supercharger adds to the vehicle's cost and electric energy use, it can improve fuel economy by as much as 20 percent. Read more at Automotive News Europe. Featured Gallery Chevrolet Spark EV View 13 Photos Related Gallery 2016 Audi Q7: Detroit 2015 View 15 Photos News Source: Hybrid Cars, EPA, Manufacturing.Net, Automotive News EuropeImage Credit: Chevrolet Government/Legal Green Audi Chevrolet Alternative Fuels Emissions Ethanol Fuel Efficiency Electric Off-Road Vehicles recharge wrapup

GM tells owners not to use SUV wipers due to fire risk

General Motors is recalling 31,685 examples of the 2016 Buick Enclave, Chevrolet Traverse, and GMC Acadia because a short circuit in the windshield wiper motor can potentially lead to a fire. Due to the danger, the company is asking owners not to use the wipers until the problem is fixed, according to The Detroit Free Press citing the Associated Press. A manufacturing defect in the wiper motor cover means that the electrical terminals can come into contact and cause a short. The part could "melt, smoke, or catch fire," according to a statement from GM. The company will get them fixed immediately, and dealers will replace the cover. If there's bad weather at the time the owner specifies to get the recall work completed, the automaker will come pick up the crossovers. Depending on parts availability, the automaker will supply a rental car for customers, as well. The issue was discovered at the factory. According to the company's statement, only 6,405 actually made it to customers, and they were notified immediately by overnight letter. The rest were in dealer stock. The affected crossovers carry build dates between August 18, 2015 and September 24, 2015. Of those, there are 29,295 in the US and 1,073 in Canada. GM Statement: General Motors has told the National Highway Traffic Safety Administration that it will recall approximately 29,295 2016 model year Chevrolet Traverse, Buick Enclave and GMC Acadia SUVs in the U.S. because the front windshield wiper motor may overheat when in use because of a manufacturing defect. In some cases, the front windshield wiper motor cover may melt, smoke or catch fire. The approximately 6,405 customers who have taken delivery of these vehicles were notified by overnight letter and are urged to contact a GM dealer as soon as possible to arrange a service appointment. These customers should not use the front windshield wipers until they have been repaired. If weather conditions prevent driving the vehicle without using the windshield wipers, GM will arrange to pick up the vehicle for servicing. If repair parts are unavailable, GM will provide a rental car at no cost until parts become available. The total population, including Canada, Mexico and exports, is approximately 31,685. About 25,280 of these vehicles are in dealer stock and will not be sold until repairs are made.