1999 Chevrolet Malibu Base Sedan 4-door 2.4l on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

2015 Chevy Volt gets larger battery, though range remains the same

The Chevrolet Volt isn't changing much for the 2015 model year. According to specifications uncovered by Inside EVs, though, the new Volt's battery does have a slightly larger capacity. According to the spec sheet, this doesn't translate to increased range. Real world driving, though, might tell a different story. The 2015 Volt's battery storage is slightly higher than the outgoing model's, up from 16.5 kilowatt-hours to 17.1 kWh. According to GM's manager of electrification technology communications, Kevin Kelly, speaking to Green Car Reports, the increased capacity is "a late change done in the cell... just another continuous improvement to surprise and delight our customers." The stated electric range, however, stays at 38 miles. Inside EVs followed up on its original report, and found that drivers could see some advantage to the battery tweak. When they spoke to Kelly, he told them, "As a result of this change, we would expect that some customers may see a slight improvement in overall EV range." It's worth noting that when battery capacity increased from 16 kWh to 16.5 kWh for the 2013 Volt, electric range increased by three miles to the current 38, while MPGe went from 94 to 98. The price of the 2015 Chevrolet Volt remains steady, at $34,995. The actual cost to the customer is considerably less with the $7,500 federal tax credit, as well as any local incentives.

Chevy shows much-improved 2014 Corvette interior in new video

If you want a closer look at what went into designing and building the interior for the 2014 Chevrolet Corvette, we've got just the thing. General Motors has released a new video detailing the cabin's evolution from conception to execution, complete with commentary from Ryan Vaughn, performance car interior design manager with Chevrolet. The quick clip details how manufacturing, engineering and design within General Motors worked together from the first sketches to ensure no compromises had to be made later down the line. How novel.
With plenty of hides traced with contrast stitching and available real carbon fiber trim, the cabin looks to be a few hundred miles ahead of the C6. Given how readily critics derided the previous generation for its cabin, the C7 should make writers work a little harder to find something to complain about. Check out the video below for yourself.