on 2040-cars

Auto blog

Fullsize GM SUVs have a problem that's making owners sick

Some fullsize SUV owners are getting sick, thanks to a buffeting and vibration problem in 2015 model year examples of the Chevy Tahoe and Suburban, Cadillac Escalade, and GMC Yukon. According to owners' complaints to the National Highway Traffic Safety Administration, the issue can vary from an annoying vibration inside the cabin to an experience so severe that it leads to dizziness and headaches. General Motors is aware of the complaints, but the fix isn't so simple. According to spokesperson Tom Wilkinson to Autoblog, the company "has been tracking this issue for a while." The problem has a fairly low incidence rate, but when it does occur the issue can be "uncomfortable and annoying for owners." There's no precise cause for the issue, Wilkinson claims, and in some cases, simply balancing the tires or changing the door seals can make it go away. However, not all of the fixes are so simple. AutoGuide dug deep into the problem and discovered a GM preliminary information bulletin that advised dealers to remove the headliner and to check the roof's bonds to the bows that go across the vehicle. However, that document included a note that the solution might not entirely eliminate things. According to AutoGuide, adding Dynamat insulation to the roof sometimes helped the problem. A GM spokesperson also told AutoGuide the company fixed the problem at the end of the 2015 model year, and didn't go into any more detail. This roof issue seems linked to some of the worst droning in these SUVs. According to one complaint from a 2015 Suburban owner to NHTSA: "Roof will not remain attached to the roof bows. This causes the buffeting similar to a window being down when all are up. The results span from annoying to painful." A 2015 Yukon owner claims to have another alleged cause for the problem in a NHTSA complaint from February 2015. This person brought their SUV to the dealer seven times over the course of four weeks for vibrations. The dealer replaced the driveshaft, suspension components, and more, but nothing worked. According to an engineer to the service adviser: "In an effort to prevent roll overs, they designed the frame and body mounts too stiff. There are 40 engineers working on issues, they have no solutions that work across the board." Wilkinson told Autoblog that GM is working with customers on an individual basis to rectify things. Since these are newer vehicles, dealers should also fix the problem under warranty.

GM executive chief EV engineer says reducing cost of plug-in vehicles is 'huge priority'

As we know, another major automaker investing heavily in electrified vehicles is General Motors, and it's doing things much differently than rivals BMW, Ford or Nissan. The Chevrolet Volt extended-range EV is a modest seller at its $35,000 sticker price but a huge hit with owners. The Chevy Spark BEV, still in limited availability, puts smiley faces on its owners and drivers. The just-introduced Cadillac ELR, a sharp-looking, fun-driving $76,000 luxocoupe take on the Volt's EREV mechanicals, has admittedly low sales expectations. With this interesting trio in showrooms and much more in the works, the third vehicle electrification leader I collared for an interview at Detroit's North American International Auto Show (see #1 and #2) was Pam Fletcher, GM's executive chief engineer, Electrified Vehicles. ABG: Why do your EREVs need four-cylinder power to extend their range when BMW's i3 makes do with an optional 650 cc two-banger? "We designed [the Volt and the ELR] to go anywhere, any time" - Pam Fletcher PF: I get that question all the time: why not something smaller? You don't really need that much. You use the electric to its ability, then you just need to limp. But we designed those cars to go anywhere, any time, and we don't want their performance to be compromised. If you're driving through the mountains, we don't want you to be crawling up grades, or to be limited on any terrain. So it's optimized to be able to travel literally the biggest grades and mountain roads around the globe at posted speeds. Because what if you can't? Another good reason: when the engine is on, you have to run it wide open throttle, max speed, most of the time. And while we can do a lot with acoustics, and the ELR has active noise cancelation, a small-displacement, low cylinder-count engine at high speed, high load all the time isn't something you want to live with. That's how we came up with the balance we did among the key factors of performance, NVH [noise, vibration and harshness] and range. ABG: Where you go from here? Is the range-extender engine due for an update? PF: We know and love the current Volt, and there is still a lot of acclaim about it, so we think it's a good recipe. But we are heavily in the midst of engineering the next-generation car, which I think everyone will love and be excited about.

Pony-car sales war: Mustang vs. Camaro vs. Challenger [UPDATE]

Update: An earlier version of this story misstated the 2015 Mustang's weight when compared with previous models. Additionally, we have added comments from Chevrolet in the text. The Ford Mustang has blown past the Chevy Camaro as America's best-selling pony car, and in June, it wasn't even close. The 'Stang outsold the Camaro 11,719 to 8,611 cars. The Camaro remained ahead of the Dodge Challenger, which sold 6,845 units. Even though the Camaro did post an 11.5-percent sales improvement in June, the competition is arguably stronger than at anytime since the 1970s muscle-car era. The Mustang's sales leapt a whopping 53.6 percent, while the Challenger saw a gain of 56 percent. Several factors are weighing down Camaro sales, including its lame duck status. Chevy is launching a new generation of the Camaro this year that's more than 200 pounds lighter, offers a new turbo four-cylinder engine option, and has a nicer interior than the outgoing model. Put simply: wait a few months and you can get a better car. It's also unlikely Chevy will jack up the price much, as it's historically kept the Camaro within reach of everyday enthusiasts. While Chevy fans wait in anticipation for their new sports car, Ford and Dodge have downshifted. The new Mustang, which went on sale last year, is faster and more sophisticated than its predecessor. It also offers a 2.3-liter EcoBoost four-cylinder, which Ford has credited for the Mustang's recent uptick and makes up 36 percent of the car's sales, Ford analyst Erich Merkle said. View 17 Photos June's performance allowed the Mustang to widen its sales gap with the Camaro this year. Through the first five months, Ford sold 68,290 Mustangs, a 54.4-percent increased compared with 2014. Chevy sold 42,593 Camaros, an 8.7-percent decrease. The Challenger – long the No. 3 pony car in sales volume – has seen its sales surge 41 percent this year to 37,011 units. Spokesman Monte Doran said Chevy expected that 2015 would be a "relatively soft year" for the Camaro. "Mustang is taking advantage of years' worth of pent-up demand for an independent rear suspension," he said. "When Camaro introduced an IRS, in 2009, it helped make us the best-selling performance car in America.