2012 Chevrolet Cruze Eco on 2040-cars

Auto blog

How GM engineers are using diaper 'snow' to keep you warm

Testing how snow affects General Motors' vehicles isn't really a problem right now for the company's engineers, but in the dog days of summer the process isn't exactly easy. The only real option is for them to book time at the automaker's climatic wind tunnel. However, a flash of brilliance from an engineer allows snow to be simulated regardless of the temperature outside, and the discovery is all because of his daughter's wet diaper. The realization came to GM Thermal Systems engineer Nicholas Jahn while he was swimming with his daughter and noticed how her diaper ballooned in size in the water. He found out the substance that makes this possible is called sodium polyacrylate. When the material gets wet it grows and forms fluffy flakes that are a close imitation of snow. Best of all, the stuff can be prepared easily any time of the year, and it's reusable. The engineering team uses the material to test the effectiveness of the heating systems of GM's vehicles. They spread the sodium polyacrylate over the inlets at the base of the windshield to obstruct the airflow and then crank the heater. After some time, they can see how much is being sucked into the system and design more efficient systems in the future. See how the process works in the video above and read about the diaper discovery in GM's press release below. Diapers Change Chevy Cruze Winter Warm-up Time GM validation engineer uses diaper material "snow" to reduce frigid drives 2015-01-06 DETROIT – An item commonly found on an infant's changing table is helping General Motors' engineers simulate snow year round, ensuring heating systems in cars like the 2015 Chevrolet Cruze can quickly and efficiently warm its interior. Packed snow can prevent air from entering the inlet panel at the bottom of the windshield, obstructing the flow of air into the heating system and reducing the amount of air it can push out. This can lead to less efficient warming of the car's interior and windshield defrosting. "The last thing anyone wants to do when it's freezing cold out is scrape their windshield," said Nicholas Jahn, GM Vehicle Thermal Systems engineer. "The testing we perform on the Chevrolet Cruze with the diaper material allows us to maximize the car's heating capabilities." Ironically, Jahn stumbled upon his diaper-based testing method in the middle of summer. During a swim with his daughter, he noticed her diaper multiplied in size when it came into contact with water.

GM recalling nearly 4,000 vehicles over airbag concerns

Four different General Motors vehicles from the 2012 model year are being recalled over a potential airbag issue. The driver's side airbag shorting bar in the 2012 Buick Verano and 2012 Chevrolet Camaro, Cruze and Sonic might make contact with the airbag terminals, even during a crash. If so, the airbag won't deploy when it should, possibly increasing injury to the driver.
The recall is expected to begin on February 13 for the 3,896 units that might be affected. GM will notify owners who can then take their vehicles to dealers to have the airbag coil replaced. A bulletin from the National Highway Traffic Safety Administration below has more info.

Opel CEO talks new EV, will likely be fresh face for Chevy, too

The rumored demise of the Opel Ampera has been confirmed, but there's good news, too. Opel CEO Karl-Thomas Neumann has been busy Tweeting information about the brand's next plug-in vehicle, admitting that the Ampera is on the way out but that plug-in vehicles are here to stay. His Tweets, in full, read: After the eventual run-out of the current generation Ampera, we'll introduce a successor product in the electric vehicle segment. Our next electric vehicle will be part of our massive product offensive – with 27 new vehicles in the 2014-2018 time frame. We see eMobility as important part of the mobility of tomorrow and we will continue to drive down costs & deliver affordability. As we learned earlier this week, the Ampera will not be refreshed when the current Chevy Volt is updated, most likely because of slow sales. Opel sold just 332 Amperas in the first five months of 2014. For now, General Motors is still building Amperas in Michigan for export to Europe. So, what might this new EV mean for the General Motors plug-in fleet? Official spokespeople are being quiet, but we think it's safe to say the new EV Neumann is talking about is not simply a rebadged Chevy Spark EV. This is the first official word about an entirely new EV, and we expect it will come to both the Chevrolet and Opel brands.