1971 Camaro on 2040-cars

Auto blog

GM recalls 8,500 Chevrolet Malibu models for rear suspension glitch

According to a letter from General Motors to the National Highway Traffic Safety Administration, flaws in the build process of the 2013 Chevrolet Malibu have led to the recall of 8,519 cars. Units built between December 6, 2011 and January 15, 2013 may have been assembled with rear suspension cradles that had insufficient torque applied to certain bolts. That out-of-spec assembly could lead to issues ranging from slight noises to a loss of vehicle control.
The problem was first noticed in December of last year by a GM test fleet driver and eventually tracked back to the improperly torqued bolts on the suspension cradle assembled through July 2012 by a supplier located not too far from the Malibu's Detroit/Hamtramck Assembly Plant. Since an official NHTSA recall notice has not been issued yet, it isn't clear whether or not Detroit-built Malibus were the only ones affected (the 2013 Malibu is also built at GM's Fairfax Assembly Plant in Kansas City, Kansas). Dealers will fix the problem by inspecting vehicles for proper torque specs, retightening if not within specs and, in some cases, perform a rear-wheel alignment.

Smaller Cars Endure Big Problems On Crash Test

In a crash test of 11 of the smallest cars on the market, only one vehicle received an acceptable rating. The rest received marginal or poor ratings in the study, providing evidence that supports a widely held notion that smaller cars are among the least safe on the road. No other vehicle group has performed as poorly on a new crash test than these mini cars, says the Insurance Institute for Highway Safety, the nonprofit group that conducted the testing. The latest results of which were released Wednesday. The Chevrolet Spark was the only car earning an overall "acceptable" rating on the small-front overlap test, and even that vehicle had its shortcomings, IIHS said. "Small lightweight vehicles have an inherent safety disadvantage," said Joe Nolan, the senior vice president for vehicle research at IIHS. "That's why it's even more important to choose one with the best occupant protection. Unfortunately, as a group, minicars aren't performing as well as other vehicle categories." The Mazda2, Kia Rio, Toyota Yaris and certain Ford Fiesta models all received "marginal" overall grades on the test, while the Mitsubishi Mirage, Nissan Versa, Toyota Prius C, Hyundai Accent, Fiat 500 and Honda Fit all earned "poor" ratings. Results from these sub-compact cars fare much worse than vehicles sized just a little bit bigger, IIHS said. Among 17 cars evaluated in the small category, five earned "good" ratings and five more earned "acceptable." Only introduced a year ago, the small-front overlap test has quickly become a key indicator of differences in automotive safety. IIHS introduced it as a way to replicate what happens when the front corner of a vehicle collides with a tree or utility pole at 40 miles per hour. In the real world, these sorts of accidents are more dangerous than others, in part because they bypass the front-end crush zones on most cars. TOP 5Most Researched Sedans 2013 Honda Accord MSRP : $21,680 2013 Hyundai Sonata MSRP : $20,895 2013 Nissan Altima MSRP : $21,760 2014 Honda Accord MSRP : $21,955 2013 Toyota Corolla MSRP : $16,230 Automakers have been rushing to make design changes to the front ends of their cars. Without a grade of acceptable or better, they cannot qualify for the IIHS' overall Top Safety Pick+ honor, given annually to the safest models on the market.

Recharge Wrap-up: NEDC's NOx problems, autonomous Chevy Volts

The International Council on Clean Transportation (ICCT) found a significant difference in NOx emissions in Euro 6 diesel cars in NEDC and WLTC testing. While 88 percent of the cars tested met emissions standards for NEDC, NOx emissions averaged five times higher under WLTC, with only 27 percent of vehicles under the limit. WLTC is considered to be a more realistic driving cycle, using hot starts and factoring a higher top speed as well as harder and more frequent accelerations than the NEDC. Read more at Green Car Congress.GM Canada will build a fleet of autonomous 2017 Chevrolet Volts. The self-driving Volts will be deployed for testing at GM's Warren, Michigan Technical Center. Employees will be able to use a carsharing app to reserve a car, which will then drive itself to the set destination. The project will allow GM to collect important data and experience to help the company more quickly develop autonomous driving technology. Read in a press release more from GM Canada, or at Green Car Congress.Carwatt is showing an electric Renault Trafic powered by second-life batteries at the COP21 environmental summit in Paris. The lithium-ion batteries used to power the EV were recycled from other Renault EVs. With the electric Trafic, Carwatt – a company that converts vehicles to use electric power – aims to demonstrate the "circular economy" of batteries, which can provide more value through a longer lifecycle. Read more in the press release below. Carwatt presents a unique automotive application for second-life batteries from electric vehicles. On the sidelines of the COP21 summit, in the Solutions Gallery running from 2 to 9 December 2015 in Le Bourget near Paris, Carwatt and its partners —Renault, Paris City Council, BPI France, the Ales Ecole des Mines Engineering School, and the Bobigny Business Campus — are showing a very special electric Renault Trafic. This prototype vehicle, the only one of kind in the world, is powered by second-life lithium-ion batteries recycled from Renault electric cars. Circular economy at work with electric vehicles When, over time, the batteries of a Renault electric vehicle fall the performance threshold specified for their initial automotive power duty (around 75% of initial capacity), they can still provide valuable service in "second-life" applications before end-of-life disposal at a recycling centre. Experiments are already under way on power storage applications, for example.