Extrem on 2040-cars

Auto blog

GM opens official investigation into C8 Corvette transmission leaks

In March 2020, a month after Chevrolet began customer deliveries of the 2020 C8 Corvette, a GM dealer technician created a Reddit thread about a leaking gearbox in a Corvette with 32 miles. That car hadn't even been sold yet. Since then, as a search of "C8 Corvette transmission leak" shows, it's been tales of woe for some owners. Something in the Tremec TR-9080 transaxle in the back of the mid-engined Corvette doesn't work as it should, the fault able to cause codes that the transmission needs service, or that the driver needs to shift to park. In some cases, the battery would die because of follow-on issues after the initial transmission code, that code preventing the car from powering down. As Autoevolution reports, GM filed paperwork with the National Highway Traffic Safety Administration in August to look into what's going on. Between forum threads and GM's investigation document, there are several issues mentioned. The most common appears to be the dual-clutch transmission leaking fluid due to gasket failures like the one suffered by one owner at 858 miles, and another for an owner currently enduring a second leaking transmission. The Midengined Corvette Forum reported that Chevy engineers redesigned the TR-9080 pan, fitting Corvettes with the new unit at some point in the 2021 model year. The original pan was stamped steel unit affixed to the engine with two studs and 13 bolts, plus "reinforcement plates." The updated pan is said to be a cast aluminum unit affixed with two studs and 17 bolts, omits the reinforcement plates, and gets a new machined new groove around its edge to seat the gasket seal. The GM paperwork now at the NHTSA mentions a P1789 code, and says one reason for it could be "debris on the park position sensor magnet causing an incorrect position reading to the TCM." This might be caused by another issue mentioned in forums, which is clogged transmission filters. GM gives instructions for returning transmission filters to the company, and a poster on one forum said the Corvette tech at the dealer where he bought his Corvette told him the automaker "requires every used transmission filter to be returned to GM."  Whatever's going on, the problems haven't stopped, and they go beyond the P1789 code. Over the weekend, a 2022 Corvette owner posted on Corvette Forums that he got a check engine light on his car after just 850 miles.

GM's Ultium EV platform finally shows up in Q3 sales numbers

General Motors has heralded its Ultium battery-electric platform as the future of its passenger car and truck lineup, but for the first two years of its existence, its impact on the marketplace has been virtually nonexistent. Well, that finally changed in the third quarter of 2023, and while the cars based on this architecture don't represent anywhere near the volume of GM's broader combustion portfolio, we're reaching a point where Ultium products are finally in view (and in the hands) of real-world shoppers. At this point, five U.S.-market Ultium models are in production: the GMC Hummer EV, Cadillac Lyriq, Chevrolet Blazer & Silverado EV, and BrightDrop Zevo 600. If you're not familiar with that last one, that's OK; it's a commercial product that you likely won't see on the road for some time. Together, these four combined for 4,257 sales in the third quarter alone — up from 2,663 for the entire first half of the year. While that may not seem like a significant uptick when viewed from altitude, the quarter-to-quarter numbers paint a clearer picture.  Let's toss out the stragglers first. The Chevy Blazer EV, and Silverado EV for example, are barely in production. GM delivered 19 Blazers and 18 Silverados in the third quarter and that's the entirety of their production runs so far. Likewise, GM's BrightDrop Zevo 600 delivery van effectively exists apart from the consumer marketplace, so its contribution of just 35 units can be set aside too. That leaves us the two you've heard of: the GMC Hummer EV and Cadillac Lyriq — models with high sticker prices and long reservation queues.  Through the second quarter (remember, we're talking six months here), GMC sold 49 Hummer EVs. No typo. In the three months that made up the third quarter, GM moved 1,167 of them. Not only is that a dramatic improvement over the first half, but it's more Hummers than GMC sold in the entirety of 2022 (854). Lyriq's improvement was less eye-popping on paper, but after moving just 122 total units in 2022 and 2,013 of them in the first half of 2023, Cadillac managed to up that figure to 3,018 units in the third quarter alone.  GM is betting its short-term EV future on the Ultium platform, so these trends need to continue if that's going to be a profitable wager.

EarthCruiser adds a bigger camper option to its heavy duty pickup line

EarthCruiser is a camper and expedition vehicle company based out of Oregon that we've previously covered for its huge commercial truck-based machines. But they offer more than that, from drop-in campers for smaller pickups to heavy duty pickup conversions. The company's latest product is one of the latter, offering a larger camping area than the current EXD model. This new camper conversion is called the Terranova. The big differentiator between it and the EXD is the camper section, which extends over the truck cab on the Terranova. This means that bed space can be moved to above the truck cab, instead of having to use a convertible dinette. So less reconfiguring, and generally more usable space. One other major difference is that the EXD is only available for the Ram 3500 and Ford F-350. The Terranova is being designed for both of those trucks as well as the Chevy Silverado 3500. The EarthCruiser Terranova is otherwise very similar to other EarthCruiser models. The camper section is made of fiberglass and plastic, and the pop-up roof is insulated with foam. The curtains are triple-layered. The company says it can house four people. It comes with a freshwater tank and pump to help supply the kitchen sink, drinking water tap, bathroom sink and indoor and outdoor showers. There's also a cassette toilet. The kitchen features an induction stove top and small refrigerator and freezer. A fan system is standard, and air conditioning is optional. Power comes from a 400-aH lithium-ion battery. The Terranova isn't yet available. EarthCruiser is finishing up design and engineering, and it plans to have finished examples early next year. The company is taking reservations now, though. Pricing hasn't been announced, but an EXD runs between $220,000 and $265,000, and we would expect the Terranova to cost even more. Related Video: Featured Gallery EarthCruiser Terranova Expedition Camper renderings Chevrolet Ford RAM Truck Off-Road Vehicles Special and Limited Editions RVs/Campers