1955 Chevrolet Truck !! on 2040-cars

Auto blog

Chevy's 6.6-liter Duramax is pretty much all new

To say there's a heated battle in heavy-duty pickups is an understatement, with Chevrolet, Ford, and Ram constantly trading blows of increased torque, horsepower, and towing capacity. The latest salvo is the revised, more powerful turbo diesel 6.6-liter Duramax V8 in the 2017 Chevy Silverado. It has 910 pound-feet of torque, an increase of 145, putting it nearly level with the Ford Super Duty. Here's a closer look at where those gains come from. How exactly did Chevrolet add all that torque plus 48 horsepower? The automaker essentially took a fine-tooth comb to the entire engine. Chevy says it changed 90 percent of the V8, and the cumulative effect of those small changes adds up to big increases. As you might guess, the turbocharger is updated. The larger unit features electric actuation of the variable nozzle turbine (VNT), and what Chevy calls a double axle cartridge mechanism that separates the VNT moving parts from the housing. That helps with heat performance as well, with a claim that the exhaust side of the turbo can run continuously up to 1,436 degrees Fahrenheit. Helping that cause are six exhaust gaskets made of Inconel - an nickel alloy that contains chromium and iron – and upgraded stainless steel for the exhaust manifold. Despite having the same cast iron cylinder block, albeit with some minor enhancements, the engine has new cylinder heads, pistons, piston pins, connecting rods, and crankshaft, which have all been upgraded to handle 20 percent higher cylinder pressures. Alongside the increase in pressure, Chevrolet also increased the cylinder head's structure with a honeycomb design. The pattern features high-strength aluminum with dual layer water jackets that not only improve strength, but also optimize water flow for better cooling. For 2017, the cylinder head also benefits from integrated plenum that aids the engine in getting more air under heavy loads. The cylinder head isn't the only component to get a minor update, as the pistons have a larger diameter pin for improved oil flow. The same detailed improvements has been bestowed to the humble connecting rods (second in our hearts only to the inanimate carbon rod). The new design has the bolts oriented roughly 45-degrees to the rod instead of parallel. The angle split design, as it's called allows for easier passage through the cylinder.

Recharge Wrap-up: Phoenix Cars delivers ZEUS to Navy, Volt saves gas compared to i-MiEV

Phoenix Cars has delivered its first Zero Emissions Utility Shuttle (ZEUS) flatbed truck to the US Navy. The electric flatbed will be used to transport maintenance materials around Naval Base Ventura County Port Hueneme. The Phoenix ZEUS features a 100-mile range, and can charge in just three hours. It also features vehicle-to-grid technology and direct power capability, allowing it to function as a mobile power station. ZEUS customers enjoy an eight-year/300,000-mile battery warranty and round-the-clock technical support from Phoenix. Phoenix launched an electric passenger shuttle last year, and years ago worked on an electric sport utility truck before shifting over to larger vehicles. Read more in the press release from Phoenix Cars. A man found that he used less gas by trading in his Mitsubishi i-MiEV for a Chevrolet Volt. Ben Rich saved fuel in part by using his Volt for road trips rather than needing to rent cars. Rich also found other benefits to driving a Volt, including more comfort, more freedom of movement and less range anxiety. Rich often had to turn off the heat in the winter to eke out precious miles in the Mitsubishi, which he needn't do in the Chevy, though he did have a gripe about the Volt using the gas motor to warm the car. Read more at Green Car Reports. EV drivers using the ChargePoint network have traveled over 196 million miles without gasoline. ChargePoint has tallied over 9 million charging sessions for a total of 65 gigawatt hours of energy. Based on national efficiency averages of three miles per kWh and 23.9 miles per gallon, this has saved 8.2 million gallons of gasoline and 60 million pounds of CO2. This accounts for what ChargePoint calls a "huge environmental impact." Read more in the release from ChargePoint below. The Environmental Impact of ChargePoint Drivers Campbell, Calif.– We all know electric vehicles (EV) have enormous environmental advantages over gas vehicles. Plug-in EVs reduce carbon-based greenhouse gases, improve air quality and reduce our dependence on fossil fuels. EV drivers on the ChargePoint network have had a huge environmental impact. With over 9 million charging sessions delivering 65 gigawatt hours of energy, EV drivers have avoided over 60 million pounds of CO2 and 8.2 million gallons of gasoline, and driven over 196 million gas-free miles. *Based on national averages: EV efficiency of 3 miles per kWh, gas efficiency of 23.9 mpg and a net savings of 0.924 pounds of CO2 per kWh.

GM to squeeze out more production capacity for midsize trucks

General Motors was predicting a strong showing for the Chevrolet Colorado and GMC Canyon before they debuted, and demand among dealers for the midsize trucks even exceeded company's expectations. The positive situation has left GM with a problem, though: finding ways to increase capacity for the pickups at the Wentzville Assembly plant in Missiouri. With a third shift already running, GM has continued to look for ways to build just a few more of the trucks at the plant. The company has plans to hire as many as 1,000 more workers for the Saturday and Sunday shifts to construct an additional 2,000 pickups a month, according to unnamed insiders at the factory speaking to Automotive News. The little adjustments even extend to getting rid of an unpaid break to add 18 minute of assembly time over the course of a day, which equals about 3,500 more vehicles a year. All of this effort comes because the trucks are in such high demand. According to GM's figures, the company has delivered a combined 35,720 units of the Colorado and Canyon from January through April 2015, and the Chevy was the fastest-selling truck in the US for the previous three months. In May, it spent an average of just 12 days in showrooms before being snapped up. And even better for the company, 43 percent of these buyers came from other brands. According to Automotive News, the most popular trade-ins have included the Ford F-150, Toyota Tacoma, and Dodge Dakota. Related Video: