1960 Chevrolet Impala on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Recharge Wrap-up: 'Racing Extinction' Tesla, Wards praises 3 hybrids

The makers of Racing Extinction used a tricked out Tesla Model S for their movie. The artists and activists used the electric car as a platform to project images from nature in various cities to raise awareness about imperiled wildlife. In addition to a the high-powered projector, the Model S features a electroluminescent paint job that emits light to mimic creatures found in the wild, such as bioluminescent sea life. It also has a thermal imaging camera in the front of the car with a filter to view CO2 emissions. Check it out in the video above, and read more at Ecomento. WardsAuto has named the 2016 Hyundai Sonata Plug-In Hybrid's powertrain to its list of 10 Best Engines. As the first plug-in hybrid to make the list, WardsAuto World Editor-in-Chief Drew Winter praises Hyundai engineers for their "impeccable job blending fuel efficiency with refinement and daily usability." Wards notes the car's smooth transitions between electric and hybrid modes, and a well-connected six-speed automatic transmission. Other electrified vehicles to make the list are the 2016 Chevrolet Volt and 2016 Toyota Prius. Read more from Hyundai, at Green Car Reports. FEV's plug-in hybrid battery pack has gone into vehicle series production. The 10-kWh battery pack, developed by the German development services provider, offers an all-electric range of about 30 miles. FEV says its battery management algorithms are just as important as choosing the right battery hardware. "The core system for the battery development is our own mature battery management system (BMS), now in its third generation, that together with optimized algorithms allows a very reliable and stable control of the battery," says FEV's Dr. Michael Stapelbroek. Read more at Green Car Congress, or in the press release from FEV below. Hybrid Vehicle Goes Into Series Production FEV development competence consists of batteries, controls, as well as complete drive systems FEV has demonstrated competence in the development of alternative drive concepts for almost twenty years. Most recently, yet another plug-in hybrid vehicle has gone into series production with technology provided by the Aachen-based developer. In addition to using an innovative transmission concept which is based on a FEV patent, FEV also developed the battery technology of the plug-in hybrid vehicle to series production readiness.

GM throttles back Chevy Malibu, Buick LaCrosse production over swollen inventories

As inventory of the Chevrolet Malibu and Buick LaCrosse continues to pile up, General Motors will be idling its Fairfax Assembly Plant for two weeks, according to Automotive News. This move comes about a month after the plant was shut down for three weeks in late December and early January for the same reason. As of January 31, the GM had a 94-day supply of Malibu stock while the LaCrosse was a little worse with a 117-day supply.
Just last week, GM announced that it would be investing $600 million in upgrading this plant, but it's unclear what future plans the company has in store for Fairfax considering slow sales of both the plant's models. We do expect a refreshed and more luxurious LaCrosse shortly and an early design update for the Malibu to be announced at some point this year, although we have had no official word as to when either will happen.