2000 Chevrolet C3500 on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Chevy Volt owners log half a billion electric miles, 2015 production starts

As General Motors gets ready to start 2015 Volt production Monday, Chevrolet is looking back at some of the numbers that got the car to where it is today. The headline number is that Volt owners have collectively put more than a half-billion electric miles on their cars. The unsurprising upshot is that, if you went out and bought a Volt, you're pretty keen on getting as many electric miles out of it as possible. 90 percent of all Volt trips are done purely on electric power. The typical Volt driver goes 970 miles between fill-ups, GM says, and that means that 63 percent of all miles are done on battery power. General Motors executive director Larry Nitz gave AutoblogGreen a few more details on the usage habits of Volt drivers, including that 81 percent of commuting miles are electric. Two-thirds of US Volt drivers charge their vehicle 1.4 times a day, a clear indicator of drivers trying to maximize electric miles through opportunity charging. In fact, Nitz said, 90 percent of all Volt trips are done purely on electric power. GM also says that the Volt's official 35 miles of electric range is still doable for many owners who have had their car for more than 30 months. Looking ahead, we know that one upgrade for the 2015 Volt will be 4G LTE connectivity that can turn the car, like others in the GM family, into a mobile wifi hotspot. We're of course much more interested in when GM is finally going to start production of the next-gen Volt, but GM officials would only tell us that they're very excited about the still-secret vehicle, promising we'll be learning more "soon." Nitz did confirm that today's Volt drivers are most interested in three things from the next-gen model: more range, a lower price and a fifth seat. He did not say whether or not GM will be able to deliver on those requests. Chevrolet Volt Owners Surpass Half a Billion Electric Miles After 30 months of use, a sampling of Volts shows consistent all-electric range 2014-06-19 DETROIT – Since its launch in late 2010, Chevrolet Volt owners have accumulated more than half a billion all-electric miles. Additionally, based on a General Motors' study of more than 300 Volts in service in California for more than 30 months, many owners are exceeding the EPA-rated label of 35 miles of EV range per full charge, with about 15 percent surpassing 40 miles of range.

2020 Chevrolet Tahoe, Suburban and GMC Yukon all spied with production lights

One of our spy photographers just caught a smattering of full-size GM SUVs out testing, including the Chevrolet Tahoe, Suburban and GMC Yukon. Previous spy photos of the next-generation of these big GM SUVs have revealed that GM is going with an independent rear suspension design, and these shots confirm the news once again with our best look at the hardware yet. Check them out from the rear, lined up like ducks in a row to see the beefy control arms down there. This will undoubtedly give the big SUVs a more compliant ride, and should bring it back into touch with the refinement from the Ford Expedition and Lincoln Navigator. The new bits we get to see with these shots are production headlights and taillights that are shaping up to look pretty neat. Most distinguishable are the GMC Yukon's LED DRLs. These look a lot like the C-shaped LEDs outlining the headlights on the Sierra, but they have an extra LED strip on top of the C. The parts of the taillights that we can see look significantly different than that found on the Sierra, showing GM is planning on having a great deal of differentiation there. We can sort of see through the mesh covering the grille to what appears to be a classic horizontal bar style front opening. Chevy is predictably dialing the crazy LED strip design back for the Tahoe and Suburban. The parts that are lit up look a whole lot like the headlight fixtures on the 2019 Silverado. That truck uses a stack of lights with the actual headlights separated from the DRLs. We can see the same thing going on here, with the headlight up top and curved LED DRL strip sitting below. It's tough to say if the designs are exactly alike, but we expect to see an extremely Silverado-esque look once all the camouflage comes off. Chevrolet's taillight design differs from its donor truck like the GMC, showing off a curved, vertical series of LEDs out back. Once production lights start popping up like this, we know the vehicle is moving closer to its end game. A reveal sometime later this year could be in the cards for GM's next batch of full-size SUVs. It certainly needs them quick, as Ford rockets ahead with increased Expedition production announced earlier this week.