1985 Chevrolet Silverado K10 on 2040-cars

Auto blog

Some 2012-13 Chevy Volts may not have enough battery coolant

The 2012 and 2013 model year Chevrolet Volt extended-range plug-in vehicle may have a battery glitch caused by low coolant levels. No recall has been issued and General Motors is taking care of the issue at no cost to drivers. Some of the affected Volts may have lower-than-advisable coolant levels because of some pesky air pockets in the car's cooling circuit. When the coolant levels get too low, the charging system for the battery powering the car's onboard generator (i.e. the Rechargeable Energy Storage System, or the RESS) may be shut down, turning one's Volt into a run-of-the-mill gas-powered car, and a pricey one at that. The Car Connection says GM is advising owners of the '12 and '13 Volts to contact their local Chevy dealer for a free fix. GM representatives didn't immediately respond to a request for comment from AutoblogGreen for more details. We believe this is a separate issue than the one that brought 8,000 Volts back to the dealers for a battery coolant fix, what GM called a "voluntary customer satisfaction effort," a few years ago. General Motors sold 23,094 Chevy Volts last year after selling 23,461 Volts in 2012, so that fix-it list may get fairly lengthy. Check out a GM-Volt.com user thread related to this issue here. *UPDATE: Chevrolet spokesman Randy Fox confirmed in an e-mail to AutoblogGreen that the company issued a service bulletin to dealers that they may need to top off coolant levels on certain Volts because of the issue, and that the vehicle will "return to normal charging operation" once that's done.

2015 Chevy Volt gets larger battery, though range remains the same

The Chevrolet Volt isn't changing much for the 2015 model year. According to specifications uncovered by Inside EVs, though, the new Volt's battery does have a slightly larger capacity. According to the spec sheet, this doesn't translate to increased range. Real world driving, though, might tell a different story. The 2015 Volt's battery storage is slightly higher than the outgoing model's, up from 16.5 kilowatt-hours to 17.1 kWh. According to GM's manager of electrification technology communications, Kevin Kelly, speaking to Green Car Reports, the increased capacity is "a late change done in the cell... just another continuous improvement to surprise and delight our customers." The stated electric range, however, stays at 38 miles. Inside EVs followed up on its original report, and found that drivers could see some advantage to the battery tweak. When they spoke to Kelly, he told them, "As a result of this change, we would expect that some customers may see a slight improvement in overall EV range." It's worth noting that when battery capacity increased from 16 kWh to 16.5 kWh for the 2013 Volt, electric range increased by three miles to the current 38, while MPGe went from 94 to 98. The price of the 2015 Chevrolet Volt remains steady, at $34,995. The actual cost to the customer is considerably less with the $7,500 federal tax credit, as well as any local incentives.

GM recalls select Chevy Cruze, Sonic and Buick Verano models over airbag issue

General Motors is recalling certain 2012 Buick Verano, Chevrolet Cruze and Sonic models due to a defect in the driver's airbag system. According to the National Highway Traffic Safety Administration, the airbag has a shorting bar which may contact two internal terminals. If that happens during a crash, the supplemental restraint may not deploy, increasing the risk of driver injury. The recall includes a total of 2,949 units.
GM will contact owners and replace the steering wheel airbag coil at no cost. At this point, it's unclear when the recall will begin, though owners may contact the automaker at 1-800-521-7300 for more information. You may also take a closer look at the full NHTSA notice below.