4wd,blue on 2040-cars

Auto blog

Next-gen Chevy Silverado and GMC Sierra may use carbon fiber

It's been generally accepted that the next generation of full-size GM trucks will use some sort of strong, lightweight material for the beds while retaining steel for the cab. While aluminum seems like the most obvious choice, according to Automotive News, the Chevy Silverado and GMC Sierra will incorporate both aluminum and carbon fiber in their beds. The publication cites sources from within GM, though it seems the introduction of this comparatively exotic material mix is still a few years off. While carbon fiber is both stronger and lighter than steel and aluminum, it takes significantly more time and money to produce, essentially relegating the material to small-volume cars. The main benefit for trucks is the resulting reduction in weight to improve fuel economy without sacrificing the tough, rugged capabilities truck buyers expect. The Ford F-150 made the switch to aluminum for the 2015 model year and it's proved highly successful. It seemed like it was only a matter of time before the competition followed suit. Automotive News says that the next-gen trucks will launch with aluminum beds and that it will take a couple of years before we'll see any carbon fiber incorporated into the design. Even then, only look for the composite material on higher-trim models, with a trickle down to lower-spec trucks possible further in the future. In 2011, GM announced it was working with Japan-based Teijin Limited on a carbon fiber reinforced thermoplastic. There's a good chance that material's introduction will be on trucks. Related Video: News Source: Automotive News Plants/Manufacturing Rumormill Chevrolet GM GMC Truck

GM profits threatened by glut of pickups

Automotive News reports that General Motors may slash production or ramp up discounts in order to deal with an oversupply of pickup trucks. GM currently has more than double the standard supply of pickups, and the vehicles are threatening to dampen the automaker's profits for 2013. Typically, automakers try to sustain a 60- to 75-day supply of vehicles, but GM is currently loaded with a 139-day supply, as of last month. At the end of November, the automaker was sitting on 245,853 units.
The manufacturer says that it will adjust production accordingly before laying any incentives on the profitable pickups. Even so, there's some concern that the inventory swell could hurt the roll-out of the next-generation Chevrolet Silverado and GMC Sierra. GM actually began slowly stepping back production in August, but it's clear the company will take further action as it heads toward the end of the year and into the next. Analysts predict the automaker could reduce pickup manufacturing by nearly half in the first quarter of 2013.
That still may not be enough to keep GM from laying extra cash on the Silverado and GMC Sierra. While the company's incentive spending was down in November compared to the same month in 2011, both the Ram 1500 and Ford F-150 saw double-digit percentage increases in sales last month while the Silverado and Sierra numbers slid compared to a year prior. Incentive spending could help move more trucks and add some balance to the GM inventory surge.

Recharge Wrap-up: NEDC's NOx problems, autonomous Chevy Volts

The International Council on Clean Transportation (ICCT) found a significant difference in NOx emissions in Euro 6 diesel cars in NEDC and WLTC testing. While 88 percent of the cars tested met emissions standards for NEDC, NOx emissions averaged five times higher under WLTC, with only 27 percent of vehicles under the limit. WLTC is considered to be a more realistic driving cycle, using hot starts and factoring a higher top speed as well as harder and more frequent accelerations than the NEDC. Read more at Green Car Congress.GM Canada will build a fleet of autonomous 2017 Chevrolet Volts. The self-driving Volts will be deployed for testing at GM's Warren, Michigan Technical Center. Employees will be able to use a carsharing app to reserve a car, which will then drive itself to the set destination. The project will allow GM to collect important data and experience to help the company more quickly develop autonomous driving technology. Read in a press release more from GM Canada, or at Green Car Congress.Carwatt is showing an electric Renault Trafic powered by second-life batteries at the COP21 environmental summit in Paris. The lithium-ion batteries used to power the EV were recycled from other Renault EVs. With the electric Trafic, Carwatt – a company that converts vehicles to use electric power – aims to demonstrate the "circular economy" of batteries, which can provide more value through a longer lifecycle. Read more in the press release below. Carwatt presents a unique automotive application for second-life batteries from electric vehicles. On the sidelines of the COP21 summit, in the Solutions Gallery running from 2 to 9 December 2015 in Le Bourget near Paris, Carwatt and its partners —Renault, Paris City Council, BPI France, the Ales Ecole des Mines Engineering School, and the Bobigny Business Campus — are showing a very special electric Renault Trafic. This prototype vehicle, the only one of kind in the world, is powered by second-life lithium-ion batteries recycled from Renault electric cars. Circular economy at work with electric vehicles When, over time, the batteries of a Renault electric vehicle fall the performance threshold specified for their initial automotive power duty (around 75% of initial capacity), they can still provide valuable service in "second-life" applications before end-of-life disposal at a recycling centre. Experiments are already under way on power storage applications, for example.