Honda underreported 1,729 claims of injuries or deaths since 2003
Tue, Nov 25 2014Following an independent audit of its safety reporting procedures, Honda has found massive holes in its methodology and practices that resulted in 1,729 claims of injuries or deaths going unreported to federal authorities dating back to July 2003. The cases should have been submitted to the National Highway Traffic Safety Administration as part of its quarterly Early Warning Reports (EWRs) under the TREAD Act, but they fell through the cracks for a variety of reasons.Among these underreported cases were eight Takata airbag inflator ruptures not submitted.
Honda blames the underreporting on three factors: data entry errors, computer coding problems and "an overly narrow interpretation of what constituted a 'written notice' under the TREAD Act." The first two issues were related to the computer program that collected the claims. If employees didn't enter a date in the "written claim received" field, then they were omitted from the EWRs. Also, the company's internal component codes didn't always match those used by NHTSA, and only the ones that were the same were disclosed. Finally, third-party documents, including police reports, were not considered.
Honda says the computer error is now corrected, and the company is updating its data entry training. In the future, written and oral claims will be included in EWRs, as well.
Among these underreported cases were eight Takata airbag inflator ruptures not submitted in Honda's EWRs, including one death and seven injuries. However, the automaker claims NHTSA was already aware of all of these incidents either from the agency's own records or from the company's notification outside of the EWR process.
Unfortunately, this problem could have been stopped much sooner. The issue was first brought to light in 2011 but didn't result in a followup. NHTSA advised the automaker of discrepancies in January 2012, and it still did nothing. This third-party audit wasn't commissioned until September 2014. "Honda acknowledges that it lacked the urgency needed to correct its problems on a timely basis," it says in the announcement.
Separately, the Japanese government is starting an investigation, as well. According to Reuters, the Japanese Transport Minister has created a task force to look into the Takata recalls and find out whether Honda under-reported incidents there. Scroll down to read the company's entire statement on the third-party investigation.
Honda Responds to NHTSA Special Order Regarding TREAD Reporting
Nov 24, 2014
Company's Third-party Audit Identifies Under-reporting
Honda Taking Immediate Corrective Action to Achieve Full Compliance
American Honda Motor Co., Inc. ("Honda") today announced that it has submitted information responsive to the Special Order issued by the National Highway Traffic Safety Administration (NHTSA) regarding the automaker's Transportation Recall Enhancement, Accountability and Documentation (TREAD) Act reporting. In its response to NHTSA, Honda provided the findings of its third-party audit of TREAD Act reporting, which identified 1,729 instances of under-reporting over the past decade due to various errors, including errors related to data entry and computer coding.
"Honda takes these findings extremely seriously. We are taking immediate corrective action, and we continue to fully cooperate with NHTSA to resolve this matter," said Rick Schostek, executive vice president, Honda North America, Inc.
A fact sheet on Honda's third-party audit of its TREAD Act reporting, known as Early Warning Reports (EWR), provides a summary of the key findings and corrective actions.
# # #
Fact Sheet: Honda's Early Warning Report Audit & NHTSA Special Order
Origin of Honda's Third Party Audit
In September 2014, Honda commissioned a third-party audit of its TREAD Act reporting (also known as Early Warning Reports, or EWRs) to the National Highway Traffic Safety Administration (NHTSA) after certain discrepancies in reporting had been identified.
NHTSA Special Order
Once Honda received preliminary findings from the third-party audit, it requested a meeting with NHTSA, and on October 17, 2014 briefed NHTSA on the matter. On November 3, 2014, NHTSA issued a Special Order to Honda requesting information related to Honda's EWRs, and Honda submitted responsive information to NHTSA on November 24, 2014.
TREAD Act Requirements
The heart of the TREAD Act is an Early Warning Reporting obligation, which requires vehicle manufacturers on a quarterly basis to report a wide variety of information that could indicate a potential safety defect. This information includes a report on any death or injury incident that is known to Honda from a written claim or a written notice containing any allegations that injury or death may have been caused by or related to a possible defect. These claims are received by manufacturers from customers, their representatives or other sources. Death and Injury EWRs to NHTSA are required to include certain specified information about the incidents. Oral claims and notices of death or injury do not carry the same reporting requirements.
The TREAD Act also requires manufacturers to provide aggregate information about warranty claims it has paid, property damage claims (regardless of whether paid or denied), customer complaints (oral and written) and field reports. Certain field reports are required to be provided in hard copy, as well.
For complete details on the TREAD Act, please visit the NHTSA website.
Key Findings of Honda's Third-Party Audit
Honda's third-party audit has identified that it did not report to NHTSA a total of 1729 written claims or notices concerning injuries or deaths over the period of July 1, 2003, through June 30, 2014. Our review to date indicates that these were inadvertent data entry and computer programming errors. Additionally, the audit found a delay between the time that Honda first became aware of possible discrepancies in its TREAD reporting and the full investigation and reporting of the issue. More detailed background regarding these issues follows:
Data Entry Errors: In entering injury and death claims into the company's database Honda often did not enter a date in the "written claim received" field. The computer program used to generate Honda's Early Warning Reports requires completion of that field in order to distinguish reportable written claims and notices from non-reportable oral claims for relief. Therefore, those written claims and notices that were input without a "written claim received" date were automatically omitted from Honda's Early Warning Reports.
Coding Error: Early Warning Reports are required to identify the particular component involved in the injury or death claims being reported using a series of NHTSA component codes. Historically, Honda maintained a more exhaustive series of its own component/defect sub-codes to track incoming claims. However, the EWR computer program was not set up properly at the outset, and did not properly map all of Honda's internal sub-codes to a NHTSA code. Therefore, when generating its Early Warning Reports, Honda's computer program included only those written injury and death claims or notices that mapped to a NHTSA component code – thus underreporting claims.
Narrow Regulatory Interpretation: Honda used an overly narrow interpretation of what constituted a "written notice" under the TREAD Act. Using this narrow interpretation, Honda did not consider third-party documentation that the company obtained through its associates or consultants as reportable. For example, police reports obtained by Honda or information from private investigators hired by the company, were not considered a "notice received by the manufacturer" – and thus did not trigger an EWR report.
Other key issues reported in Honda's response to the Special Order from NHTSA:
The TREAD Act requires manufacturers to report, by number, the warranty and property damage claims received from customers or their representatives. In reviewing its reporting of these areas, Honda determined that regular warranty claims were properly reported to the NHTSA. However, certain special warranty claims, including "good will" warranty, and extended warranties for certified pre-owned vehicles and under 3rd party service contracts were not properly reported.
Further, instead of reporting all property damage claims, as required, Honda was reporting only property damage claims that it had denied, while those claims that it accepted and paid to customers were improperly included in the count of warranty claims. The net result is that Honda over-reported these as warranty claims and under-reported property damage claims.
This mis-reporting is a result of inaccurate regulatory interpretation and programming errors at the time that Honda's TREAD reporting was established.
Corrective Actions
In order to ensure such errors do not happen again, Honda has begun to take a number of steps that address the issues raised in the third-party audit and in Honda's review in compliance with the NHTSA Special Order. These include:
Honda has already corrected the computer programming issue and mapped the complete universe of Honda's codes to corresponding NHTSA component codes.
Honda will voluntarily include both written and oral claims of injuries or death in all future Early Warning Reports.
Honda will implement full training regarding the data entry process, including refresher training with detailed written guidelines.
Honda is in the process of enhancing its oversight of the Early Warning reporting process.
Honda will make organizational and staffing level changes in the functional areas responsible for its Early Warning reporting.
Honda will reprogram warranty and property claims to the EWR reporting system so that all warranty claims are included, and property damage reports will be included whether they are paid or denied.
A Note on the Issue of Takata Airbag Inflator Ruptures
The third-party audit of Honda's TREAD Act reporting represents an analysis of written claims reported by Honda to NHTSA since the TREAD Act took effect on July 1, 2003, compared to the total universe of written claims the company received over that time period.
While the audit captured claims related to Takata airbags, it represents a separate and distinct matter from NHTSA's current Takata airbag inflator rupture investigation. Even though eight Takata airbag inflator ruptures were not included in Honda's TREAD report, NHTSA was aware of all these ruptures either through notification by Honda or through NHTSA's own records.
Of the 1729 written claims and notices Honda did not report to NHTSA via EWRs, eight involved Takata airbag inflator ruptures (0.5 %). Importantly, all eight Takata-related written claims, including the one fatality and seven other injury claims, were disclosed to NHTSA in detail by other means. Six of these claims, including one fatality, were reported to the NHTSA with complete information in September 2009. Regarding the other two injury claims, a 2009 incident was reported in 2011, while another claim in 2013 was reported to Honda by NHTSA and was not placed in Honda's subsequent quarterly TREAD report in error.
Regarding the one fatality from the rupture of a Takata airbag inflator that Honda did not include as an EWR, Honda was notified of this May 27, 2009 incident in writing on July 2, 2009. According to the TREAD Act, Honda should have reported this death as an EWR by the end of November. As previously acknowledged, while the company did not issue this EWR, Honda provided NHTSA with all relevant information about the incident on September 19, 2009, more than two months before the report was due.
Timeline of TREAD ACT Reporting Errors:
A Honda associate first recognized an issue related to the recording of a verbal date code in the legal file management system in 2011 and believed that it could have affected the accuracy of the EWR reports; however, apparently, there was no follow-up. The NHTSA made Honda aware of its under-reporting EWRs in early January 2012. Honda began looking into the issue at that time, but did not take conclusive action. Honda began a third-party audit to determine the full extent of its under-reporting in September 2014, and first notified NHTSA of the discrepancies in Honda's Early Warning Reporting in October 2014. Honda acknowledges that it lacked the urgency needed to correct its problems on a timely basis.
# # #
Nov 24, 2014
Company's Third-party Audit Identifies Under-reporting
Honda Taking Immediate Corrective Action to Achieve Full Compliance
American Honda Motor Co., Inc. ("Honda") today announced that it has submitted information responsive to the Special Order issued by the National Highway Traffic Safety Administration (NHTSA) regarding the automaker's Transportation Recall Enhancement, Accountability and Documentation (TREAD) Act reporting. In its response to NHTSA, Honda provided the findings of its third-party audit of TREAD Act reporting, which identified 1,729 instances of under-reporting over the past decade due to various errors, including errors related to data entry and computer coding.
"Honda takes these findings extremely seriously. We are taking immediate corrective action, and we continue to fully cooperate with NHTSA to resolve this matter," said Rick Schostek, executive vice president, Honda North America, Inc.
A fact sheet on Honda's third-party audit of its TREAD Act reporting, known as Early Warning Reports (EWR), provides a summary of the key findings and corrective actions.
# # #
Fact Sheet: Honda's Early Warning Report Audit & NHTSA Special Order
Origin of Honda's Third Party Audit
In September 2014, Honda commissioned a third-party audit of its TREAD Act reporting (also known as Early Warning Reports, or EWRs) to the National Highway Traffic Safety Administration (NHTSA) after certain discrepancies in reporting had been identified.
NHTSA Special Order
Once Honda received preliminary findings from the third-party audit, it requested a meeting with NHTSA, and on October 17, 2014 briefed NHTSA on the matter. On November 3, 2014, NHTSA issued a Special Order to Honda requesting information related to Honda's EWRs, and Honda submitted responsive information to NHTSA on November 24, 2014.
TREAD Act Requirements
The heart of the TREAD Act is an Early Warning Reporting obligation, which requires vehicle manufacturers on a quarterly basis to report a wide variety of information that could indicate a potential safety defect. This information includes a report on any death or injury incident that is known to Honda from a written claim or a written notice containing any allegations that injury or death may have been caused by or related to a possible defect. These claims are received by manufacturers from customers, their representatives or other sources. Death and Injury EWRs to NHTSA are required to include certain specified information about the incidents. Oral claims and notices of death or injury do not carry the same reporting requirements.
The TREAD Act also requires manufacturers to provide aggregate information about warranty claims it has paid, property damage claims (regardless of whether paid or denied), customer complaints (oral and written) and field reports. Certain field reports are required to be provided in hard copy, as well.
For complete details on the TREAD Act, please visit the NHTSA website.
Key Findings of Honda's Third-Party Audit
Honda's third-party audit has identified that it did not report to NHTSA a total of 1729 written claims or notices concerning injuries or deaths over the period of July 1, 2003, through June 30, 2014. Our review to date indicates that these were inadvertent data entry and computer programming errors. Additionally, the audit found a delay between the time that Honda first became aware of possible discrepancies in its TREAD reporting and the full investigation and reporting of the issue. More detailed background regarding these issues follows:
Data Entry Errors: In entering injury and death claims into the company's database Honda often did not enter a date in the "written claim received" field. The computer program used to generate Honda's Early Warning Reports requires completion of that field in order to distinguish reportable written claims and notices from non-reportable oral claims for relief. Therefore, those written claims and notices that were input without a "written claim received" date were automatically omitted from Honda's Early Warning Reports.
Coding Error: Early Warning Reports are required to identify the particular component involved in the injury or death claims being reported using a series of NHTSA component codes. Historically, Honda maintained a more exhaustive series of its own component/defect sub-codes to track incoming claims. However, the EWR computer program was not set up properly at the outset, and did not properly map all of Honda's internal sub-codes to a NHTSA code. Therefore, when generating its Early Warning Reports, Honda's computer program included only those written injury and death claims or notices that mapped to a NHTSA component code – thus underreporting claims.
Narrow Regulatory Interpretation: Honda used an overly narrow interpretation of what constituted a "written notice" under the TREAD Act. Using this narrow interpretation, Honda did not consider third-party documentation that the company obtained through its associates or consultants as reportable. For example, police reports obtained by Honda or information from private investigators hired by the company, were not considered a "notice received by the manufacturer" – and thus did not trigger an EWR report.
Other key issues reported in Honda's response to the Special Order from NHTSA:
The TREAD Act requires manufacturers to report, by number, the warranty and property damage claims received from customers or their representatives. In reviewing its reporting of these areas, Honda determined that regular warranty claims were properly reported to the NHTSA. However, certain special warranty claims, including "good will" warranty, and extended warranties for certified pre-owned vehicles and under 3rd party service contracts were not properly reported.
Further, instead of reporting all property damage claims, as required, Honda was reporting only property damage claims that it had denied, while those claims that it accepted and paid to customers were improperly included in the count of warranty claims. The net result is that Honda over-reported these as warranty claims and under-reported property damage claims.
This mis-reporting is a result of inaccurate regulatory interpretation and programming errors at the time that Honda's TREAD reporting was established.
Corrective Actions
In order to ensure such errors do not happen again, Honda has begun to take a number of steps that address the issues raised in the third-party audit and in Honda's review in compliance with the NHTSA Special Order. These include:
Honda has already corrected the computer programming issue and mapped the complete universe of Honda's codes to corresponding NHTSA component codes.
Honda will voluntarily include both written and oral claims of injuries or death in all future Early Warning Reports.
Honda will implement full training regarding the data entry process, including refresher training with detailed written guidelines.
Honda is in the process of enhancing its oversight of the Early Warning reporting process.
Honda will make organizational and staffing level changes in the functional areas responsible for its Early Warning reporting.
Honda will reprogram warranty and property claims to the EWR reporting system so that all warranty claims are included, and property damage reports will be included whether they are paid or denied.
A Note on the Issue of Takata Airbag Inflator Ruptures
The third-party audit of Honda's TREAD Act reporting represents an analysis of written claims reported by Honda to NHTSA since the TREAD Act took effect on July 1, 2003, compared to the total universe of written claims the company received over that time period.
While the audit captured claims related to Takata airbags, it represents a separate and distinct matter from NHTSA's current Takata airbag inflator rupture investigation. Even though eight Takata airbag inflator ruptures were not included in Honda's TREAD report, NHTSA was aware of all these ruptures either through notification by Honda or through NHTSA's own records.
Of the 1729 written claims and notices Honda did not report to NHTSA via EWRs, eight involved Takata airbag inflator ruptures (0.5 %). Importantly, all eight Takata-related written claims, including the one fatality and seven other injury claims, were disclosed to NHTSA in detail by other means. Six of these claims, including one fatality, were reported to the NHTSA with complete information in September 2009. Regarding the other two injury claims, a 2009 incident was reported in 2011, while another claim in 2013 was reported to Honda by NHTSA and was not placed in Honda's subsequent quarterly TREAD report in error.
Regarding the one fatality from the rupture of a Takata airbag inflator that Honda did not include as an EWR, Honda was notified of this May 27, 2009 incident in writing on July 2, 2009. According to the TREAD Act, Honda should have reported this death as an EWR by the end of November. As previously acknowledged, while the company did not issue this EWR, Honda provided NHTSA with all relevant information about the incident on September 19, 2009, more than two months before the report was due.
Timeline of TREAD ACT Reporting Errors:
A Honda associate first recognized an issue related to the recording of a verbal date code in the legal file management system in 2011 and believed that it could have affected the accuracy of the EWR reports; however, apparently, there was no follow-up. The NHTSA made Honda aware of its under-reporting EWRs in early January 2012. Honda began looking into the issue at that time, but did not take conclusive action. Honda began a third-party audit to determine the full extent of its under-reporting in September 2014, and first notified NHTSA of the discrepancies in Honda's Early Warning Reporting in October 2014. Honda acknowledges that it lacked the urgency needed to correct its problems on a timely basis.
# # #
By Chris Bruce
See also: Will states start to prevent you from registering cars that have pending recalls?, Car and Driver 10Best list cracked by Tesla Model S, BMW 3 Series left off, Honda spending $13.8 million on hydrogen infrastructure with FirstElement.