2005 Volkswagen Touareg V8 - 4.2l - Low Reserve - Air Ride on 2040-cars

Auto blog

VW fix would have cost $335 per vehicle

Since the Volkswagen diesel kerfuffle began, Bosch, the world's largest auto supplier, has been hooked up to a bullhorn trying to make sure everyone knows its side of the story. Bosch supplied VW with the engine management testing software, including delivery and metering modules, that VW then used to skirt emissions laws in the US. Bosch told VW in 2007 that it was illegal to use the software in cars it planned to sell yet VW did it anyway, according to reports coming out in German newspapers Bild am Sonntag and Frankfurter Allgemeine Zeitung. That first warning came two years after VW started developing the small-displacement diesel, around the time that the two men pushing its development, then-brand chief Wolfgang Bernhard and engineer Rudolf Krebs, were telling their superiors that the engine needed AdBlue urea injection to pass US emissions. VW cost controllers wouldn't approve the AdBlue solution because it would add 300 euros ($335 US) to the cost of the vehicle. Bernhard and Krebs left the same year that Bosch advised VW about the software, two years before the engine went into production. That's when things get cloudy. A report in Automotive News says that when Martin Winterkorn took over in 2007 as head of the VW Group and brand, he asked Ulrich Hackenberg and Wolfgang Hatz to keep working on the engine, and "[the] engine then ended up in VW Group diesels" with that problematic software still intact. No one has yet pointed any fingers at this latter chain of command, but like a game of Clue, right now they're the professors in the library holding the candlesticks. Warnings didn't only come from the supplier: Frankfurter says VW's initial investigation has found that an engineer issued the same caution to the company in 2011. Neither Bosch nor VW would comment on the reports.

Cruze Diesel Road Trip reveals the good and bad, but no ugly

Most of us have strong opinions on diesel-powered cars based on our perceptions of and experience with them. I used to thoroughly dislike oil burners for their noise, smoke and lackluster performance, and the fact that they ran on greasy, smelly stuff that was more expensive than gasoline, could be hard to find and was nasty to get on your hands when refueling. Those negatives, for me, trumped diesel's major positives of big torque for strong acceleration and better fuel economy. Are any of those knocks on diesel still valid today? I'm not talking semis, which continue to annoy me when their operators for some reason almost never shut them down. At any busy truck stop, the air seems always filled with the sound – and sometimes smell – of dozens of big-rig diesels idling endlessly and mindlessly. Or diesel heavy-duty pickups. Those muscular workhorses are far more refined than they once were and burn much less fuel than their gasoline counterparts. But good luck arriving home late at night, or departing early morning, without waking your housemates and neighbors with their clattery racket. No, I'm talking diesel-powered passenger cars, which account for more than half the market in Europe (diesel fuel is cheaper there) yet still barely bump the sales charts in North America. Diesel fuel remains more expensive here, too few stations carry it, and too many Americans remember when diesel cars were noisy, smelly slugs. Also, US emissions requirements make them substantially more expensive to certify, and therefore to buy. But put aside (if you can) higher vehicle purchase and fuel prices, and today's diesel cars can be delightful to drive while delivering much better fuel efficiency than gas-powered versions. So far in the US, all except Chevrolet's compact Cruze Diesel come from German brands, and all are amazingly quiet, visually clean (no smoke) and can be torquey-fun to drive. When a GM Powertrain engineering team set out to modify a tried-and-true GM of Europe turbodiesel four for North American Chevy Cruze compacts, says assistant chief engineer Mike Siegrist, it had a clear target in mind: the Volkswagen Jetta TDI 2.0-liter diesel. And they'll tell you that they beat it in nearly every way. "I believe we have a superior product," he says. "It's powerful, efficient and clean, and it will change perceptions of what a diesel car can be." The 2.0L Cruze turbodiesel pumps out 151 SAE certified horses and 264 pound-feet of torque (at just 2,000 rpm) vs.

VW internal investigation finds 'no evidence' against suspended engineers

Volkswagen is still working out the chain of events that led to emissions-evading software being installed in 11 million diesel vehicles worldwide and deciding who was responsible for the treachery. So far, the German automotive giant's internal investigation hasn't publicly named many suspects, and three suspended executive-level engineers have been found not to be culpable in the wrongdoing, according to an anonymous insider speaking to Reuters. VW knows that the software began being installed in the EA 189 engine in 2008. The internal investigation has found that the emissions-evading tech was created because the powerplant was found to fail US standards. Plus, the diesel mill wasn't meeting cost targets, according to Reuters. The automaker responded by suspending over 10 employees, but three top engineers among them might not have been involved. Those put on leave include Heinz-Jakob Neusser from VW, Ulrich Hackenberg from Audi, and Wolfgang Hatz who led Porsche's research and group-wide engine development. The internal detective work hasn't turned up any evidence against these three men. In addition to VW's own inquires, government investigators in both the US and Germany are taking a serious look into the company's actions, too. So far, the automaker is setting aside about $7.3 billion to pay to fix the vehicles with the evasive software. Depending on what authorities find, the costs could grow quickly. Beyond the financial implications, the scandal has led to a serious shakeup in VW's corporate structure. Related Video: