2004 Volkswagen Passat Gl Sedan 4-door 1.8l on 2040-cars

Auto blog

Rising aluminum costs cut into Ford's profit

When Ford reports fourth-quarter results on Wednesday afternoon, it is expected to fret that rising metals costs have cut into profits, even as rivals say they have the problem under control. Aluminum prices have risen 20 percent in the last year and nearly 11 percent since Dec. 11. Steel prices have risen just over 9 percent in the last year. Ford uses more aluminum in its vehicles than its rivals. Aluminum is lighter but far more expensive than steel, closing at $2,229 per tonne on Tuesday. U.S. steel futures closed at $677 per ton (0.91 metric tonnes). Republican U.S. President Donald Trump's administration is weighing whether to impose tariffs on imported steel and aluminum, which could push prices even higher. Ford gave a disappointing earnings estimate for 2017 and 2018 last week, saying the higher costs for steel, aluminum and other metals, as well as currency volatility, could cost the company $1.6 billion in 2018. Ford shares took a dive after the announcement. Ford Chief Financial Officer Bob Shanks told analysts at a conference in Detroit last week that while the company benefited from low commodity prices in 2016, rising steel prices were now the main cause of higher costs, followed by aluminum. Shanks said the automaker at times relies on foreign currencies as a "natural hedge" for some commodities but those are now going in the opposite direction, so they are not working. A Ford spokesman added that the automaker also uses a mix of contracts, hedges and indexed buying. Industry analysts point to the spike in aluminum versus steel prices as a plausible reason for Ford's problems, especially since it uses far more of the expensive metal than other major automakers. "When you look at Ford in the context of the other automakers, aluminum drives a lot of their volume and I think that is the cause" of their rising costs, said Jeff Schuster, senior vice president of forecasting at auto consultancy LMC Automotive. Other major automakers say rising commodity costs are not much of a problem. At last week's Detroit auto show, Fiat Chrysler Automobiles NV's Chief Executive Officer Sergio Marchionne reiterated its earnings guidance for 2018 and held forth on a number of topics, but did not mention metals prices. General Motors Co gave a well-received profit outlook last week and did not mention the subject. "We view changes in raw material costs as something that is manageable," a GM spokesman said in an email.

VW recalling 2.64M vehicles worldwide over engine, light issues

Volkswagen is staging a massive, worldwide recall that's already grown from 1.68 million to 2.64 million vehicles and covers three different issues across a number of vehicles. We already reported on 61,000 Tiguans getting recalled over lighting issues - that was just in the US. Globally, however, VW will be recalling 800,000 Tiguans, according to Automotive News, with the focus on CUVs built between 2008 and 2011. The issue with the Tiguan relates to a simple fuse swap, so this is rather unremarkable, aside from the sheer number of vehicles being fixed. The real, troubling issues relate to gearboxes and pickups.
239,000 Amarok pickups (pictured right) are being recalled over fuel leaks, while 1.6 million vehicles are being recalled to swap the synthetic oil in dual-clutch transmissions with mineral oil. Now, the transmission issue is one for the global Volkswagen Group to address, not just the VW brand - vehicles from Audi, Škoda and Seat use the same seven-speed DSG and are covered under the recall, as well.
Why the switch from synthetic to mineral oil? Apparently, using the synthetic oil in a DSG and then subjecting it to stop-and-go conditions or heavy loads in a hot and humid climate can lead to electronic malfunctions, according to a Volkswagen press release. The switch, from the sounds of it, is largely a preventative measure.

Volkswagen finds CO2 'irregularities' for 800k vehicles

The latest issue for Volkswagen affects another 800,000 vehicles, and this time its for irregularities in CO2 emissions certifications. VW estimates this issue could cost the company $2.2 billion to fix. The company officially makes no specific mention of which engines are covered, the models they are in, or even where they are located. VW discovered the situation during its ongoing internal investigation, and, according to the automaker, "it was established that the CO2 levels and thus the fuel consumption figures for some models were set too low during the CO2 certification process." Most of the affected vehicles are diesels, and the company is now reaching out to "the responsible type approval agencies" to figure out the next step. While VW isn't officially confirming which models and engines are involved, Automotive News reports that it affects some 2012 and later VW, Audi, Seat, and Skoda models with the company's 1.4-, 1.6-, and 2.0-liter diesel engines, as well as the 1.4-liter ACT gasoline engine. The issue mainly affects vehicles sold in Europe. "The Board of Management of Volkswagen AG deeply regrets this situation and wishes to underscore its determination to systematically continue along the present path of clarification and transparency," CEO Matthias Muller said in the announcement. Volkswagen Group of America spokesperson Jeannine Ginivan was able to provide some further clarification to Autoblog. "This is not related to US-certified vehicles," she said. Clarification moving forward: internal investigations at Volkswagen identify irregularities in CO2 levels Matthias Muller: "Relentless and comprehensive clarification is our only alternative." Around 800,000 Group vehicles could be affected Initial estimate puts economic risks at approximately 2 billion euros The Volkswagen Group is moving forward with the clarification of the diesel issue: during the course of internal investigations irregularities were found when determining type approval CO2 levels. Based on present knowledge around 800,000 vehicles from the Volkswagen Group could be affected. An initial estimate puts the economic risks at approximately two billion euros. The Board of Management of Volkswagen AG will immediately start a dialog with the responsible type approval agencies regarding the consequences of these findings. This should lead to a reliable assessment of the legal, and the subsequent economic consequences of this not yet fully explained issue.