on 2040-cars

Auto blog

Recharge Wrap-up: First VW e-Golf in US up for auction, meet Project Ain't Fuelin'

Volkswagen is auctioning the first e-Golf in the US to raise money for Global Green USA. The auction is live now, and bidding goes until 3:30 pm Eastern on October 29. Global Green USA will use the proceeds to help find solutions to climate change, and the winner will get to enjoy emissions-free driving before the car e-Golf goes on sale in November. If you don't live in or near California, Connecticut, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Rhode Island, Vermont or Washington DC, you might want to sit this one out, as the car will only be available to pick up at dealers in those initial launch states. Go bid now, or learn more in the press release below. Berlin, Germany will use Solaris electric buses for a complete bus line in 2015. The downtown line will run 3.8 miles between Zoologischer Garten Station and Sudkreuz. The transport operator Berliner Verkehrsbetriebe (BVG) will use four of the Solaris e-buses for the test, each about 39 feet long. The buses use a 200-kilowatt inductive charging system at the ends of the line to recharge in just a few minutes. The government-funded test runs through 2016, but BVG pans to use the electric buses beyond that timeline. Read more at Green Car Congress. The American Petroleum Institute (API) is worried that the Obama administration will use ethanol requirements to influence a Senate race in Iowa. In the midst of a close race against Republican Joni Ernst, Representative Bruce Braley, the Democratic candidate, is urging Obama to reject a cut in the Renewable Fuel Standard. The November election approaches, meanwhile the EPA continues to delay issuing an ethanol requirement for the year, with or without its proposed 16-percent reduction. Rejecting the cut could help get farmers and ethanol producers on the side of Braley. "We are very concerned that the signals we are seeing from the administration is that the political calculations are outweighing sound fuels policy," says API's Bob Greco. Read more at Businessweek. Project Ain't Fuelin' aims to fix up old cars to return them to original fuel economy, and then surpass it. Episode 3 of Valvoline's Under The Hood video series features Daniel Gray of MPGomatic, who is doing just that to a 1999 Honda Civic HX Coupe. He aims to get 50 mpg out of the old Civic by tuning it up, tinkering with the aerodynamics, switching to more efficient tires and other modifications.

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

VW to unveil diesel-electric Twin-Up! in Tokyo

We've received multiple reports that Volkswagen will be bringing a diesel-electric concept to the 2013 Tokyo Motor Show, set to take place later this month. The car, called the Twin-Up!, is based on the Up! city car, with some sources claiming this is a thinly veiled concept that will eventually enter production.
According to Automotive News Europe, the Twin-Up! will reportedly return 214 miles per gallon on the US cycle by combining an 800-cc, two-cylinder diesel and an electric motor. It will also boast plug-in capabilities, and will be able to cover 30 miles on electric power alone.
Autocar has a more complete picture of the Twin-Up!'s powertrain, though, claiming it's a modified version of the hybrid system found in the Volkswagen XL1. The Twin-Up! will get a more potent, 47-horsepower electric motor to the XL1's 27-hp unit, but will retain that car's 47-hp turbodiesel. The battery pack will also grow, from 5.5 kilowatt hours to 8.6 kWh. Both of these increases are necessary due to the increased weight of the Twin-Up! - it's some 900 pounds heavier than an XL1.