2003 Volkswagen Beetle Gls Convertible 2-door 2.0l Sundown Orange! on 2040-cars

Auto blog

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

Feds allege widespread Volkswagen cheating on clean-air rules

Volkswagen intentionally installed software in nearly a half-million diesel vehicles that helped the cars evade substandard results on emissions tests, the federal government charged Friday. The Environmental Protection Agency issued a notice of violation to the German automaker, saying the company's software broke the law by violating two provisions in the Clean Air Act. Circumventing the standards meant affected cars emitted as much as 40 times the allowable level of certain pollutants. Both the EPA and California Air Resources Board have launched investigations. In its notice of violations, the EPA said Volkswagen officials admitted to installing and concealing what they call a "defeat device," which was designed to detect when the cars were undergoing official emissions tests – and only turn on emissions controls during that time. "Our goal now is to ensure that the affected cars are brought into compliance, to dig more deeply into the extent and implications of Volkswagen's efforts to cheat on clean air rules, and to take appropriate further action," said Richard Corey, executive officer of CARB. The allegations cover approximately 482,000 vehicles sold in the United States over the past seven years. Cars involved include diesel versions of the Jetta, Beetle, Audi A3 and Golf manufactured between the 2009 and 2015 model years. Passats manufactured for the 2014 and 2015 model years are also included. Federal officials note there is no safety danger to motorists, but the cars will be recalled for repairs. If true, Volkswagen faces a fine that could run in the hundreds of millions of dollars -- likely higher than the $300 million charge the EPA levied last November at Hyundai and Kia for exaggerating the fuel-economy in several models. The charges also put a tremendous dent into the company's plans to increase sales of its "Clean Diesel" vehicles in North America. In a written statement, Volkswagen Group of America acknowledged it had received the notices from the EPA and CARB. "VW is cooperating with the investigation; we are unable to comment further at this time," it said. Federal officials said the defeat-device software was uncovered during an independent analysis by researchers at West Virginia University, who in working with the International Council on Clean Transportation, a non-governmental organization, raised questions about emissions levels.

Volkswagen Routan dead, pour out a sippy cup for your little homies

America's minivan wolfpack has just gotten smaller by one. According to Automotive News, Volkswagen officials have confirmed what we've suspected for some time - the Routan is dead. Essentially a lightly reworked version of the Dodge Grand Caravan, the Routan actually hasn't been rolling off of Chrysler's Windsor, Ontario production line at all this year, but VW had yet to confirm its discontinuation. However, Jonathan Browning, CEO of VW America, has reportedly admitted that the Routan is being axed, with remaining units expected to be funneled into corporate functions for "internal purposes."
The move isn't unexpected - the Routan has never been a big seller, with just 57,650 examples moved since sales began in 2008 - peak yearly sales totaled under 16,000 units, and that was back in 2010. And while many have talked of the minivan segment shrinking, Automotive News points out that the segment actually grew 14 percent last year to 597,118 units, though it should be noted that most segments have been on sales upticks as the US economy chugs out of its recession.
So, is volume-crazy Volkswagen prepared to pass on large family vehicle sales? Probably not - the German automaker has signaled that it plans to build a three-row crossover in North America soon, and we wouldn't be surprised if it looks an awful lot like the Crossblue Concept from January's Detroit Auto Show - minus the fancy plug-in diesel powertrain.