1999 Toyota Tacoma X-cab 4x4 on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Vehicles awarded IIHS Top Safety Pick awards skyrockets for 2015 [w/video]

By practically every measure, passenger vehicles in the US are continuing to get safer. With the year rapidly coming to an end, the Insurance Institute for Highway Safety is releasing its annual list tallying of the scores for the latest vehicles to see how they compare to last year. Judging by the agency's evaluations, the numbers look quite positive. According to the institute, 71 vehicles earned either the Top Safety Pick or Top Safety Pick+ rating so far in its testing for 2015. Among the latest winners, there have been 33 TSP+ awards and 38 TSP medalists. That's a healthy increase over the 22 TSP+ and 17 TSP grades in 2014. The figures appear even more impressive when you consider that it keeps getting harder to earn the + designation. In the latest round of testing, a vehicle must offer some form of front crash prevention automatic braking to get the mark. Previously, just a warning to drivers was necessary. This list also illustrates the ways that automakers adapt to new testing procedures. In 2013 there were 117 TSP ratings and 13 TSP+ awards. Then, the IIHS mandated that to be a safety pick, a model had to score Good in the institute's four crash tests, plus a Good or Acceptable in the small overlap front test. That brought a plunge in 2014 to just 17 TSP grades. With the numbers climbing again, companies apparently have deciphered how to perform better. Some brands especially stood out on this year's list. The IIHS praised Volvo, Mercedes-Benz and Acura for offering standard front crash prevention systems on some models. Subaru received at least one of the awards for all seven of its models. Toyota also had seven, and the Honda brand did too – though the institute counts the two- and four-door versions of the Civic and Accord separately. Check out the full announcement below and a video about this year's winners. The full list can be viewed, here. Safety gains ground: More vehicles earn top honors from IIHS The number of vehicles earning either of the Institute's two awards has jumped to 71 from 39 this time last year, giving consumers more choices for optimum protection in crashes. The number of winners in the top tier - TOP SAFETY PICK+ - has increased by 11 for 2015, despite a tougher standard for front crash prevention. "This is the third year in a row that we are giving automakers a tougher challenge to meet," says IIHS President Adrian Lund.

Toyota's Texas move could boost state's economy by $7.2B in 10 years

They say everything is bigger in Texas, and apparently that includes the Toyota's effect on the economy. The giant Japanese automaker's new headquarters in Plano, TX, will add an estimated $7.2 billion to the state over the next 10 years, according to a new study commissioned by the city and cited by Bloomberg.
The benefits appear to be an absolute steal compared to the direct incentives that Plano and the state are giving Toyota. The report finds that by the time the automaker's campus is complete in 2018, it could have 3,650 full-time workers there at an average salary of $104,000. The city has prepared $6.75 million in grants, plus property tax discounts, according to Bloomberg. In addition to that, the state is offering the business $40 million in incentives from its Texas Enterprise Fund. This is still a fraction of what Toyota is estimated to bring in.
Toyota announced in April that it would move its US operations to Plano after being headquartered in California since 1957. The move affects thousands of employees from the sales and engineering divisions. The first workers will arrive there this fall, but Toyota will eventually have a whole campus in Plano by late 2017. The move is expected to save it huge amounts in taxation and offer employees a lower cost of living. Toyota North America CEO Jim Lentz also says that the Texas location puts the headquarters closer to more of the business' factories in the south. Texas certainly appears to be showing it some southern hospitality.