2005 Toyota Sienna Xle Limited Awd Mini Passenger Van 5-door 3.3l on 2040-cars

Auto blog

NHTSA opens safety investigations into Toyota, GM and Honda crossovers

The National Highway Traffic Safety Administration is evidently keeping itself very busy these days, as the federal agency has just announced it is launching or renewing investigations into Toyota, Honda and General Motors crossovers.
2006-2008 model year Toyota RAV4 crossovers are under review for allegations of rear tie-rod rust which can result in failure. NHTSA also said it is probing some 35 complaints about 2005 Honda Pilot models with inappropriate activation of the vehicles' stability control system. The alleged malfunction can cause the vehicles to slow down or stop in bad unsafe situations. At the moment, NHTSA is reviewing a petition regarding the Pilot issue, a move that will determine whether it needs to open a full-blown investigation.
In addition, Saturn Outlook and GMC Acadia three-row crossovers built in 2007-2009 are getting looked at for "loss of low beam headlamp" function. One complainant said the wiring in his Outlook overheated and melted. NHTSA says it has received 415 complaints about the problem and a GM spokesman confirmed that the automaker already started a "Customer Satisfaction Program" in December to address the issue.

Toyota Recalling 1.67 Million Vehicles Worldwide

UPDATE: Toyota is now announcing specifically which models are covered under its fuel pipe recall in the US. The company is repairing about 423,000 Lexus models that include the 2007-2010 LS, 2006-2011 GS, 2006-2011 IS, 2010 IS C and 2008-2010 IS-F. The automaker says that it isn't aware of any fires, crashes, injuries or fatalities caused by this problem. According to Toyota, the recall is because it's possible for the fuel delivery pipes and the fuel pressure sensor to form a bad seal with the gasket between them because of a protective coating protecting against corrosion on the pipes. It's possible for this to eventually cause a fuel leak, and obviously in a hot engine bay that's a potential fire risk. To fix the problem, dealers will replace the gasket and repair the gasket seating surface between the fuel delivery pipe and the fuel pressure sensor. The company will begin notifying owners soon. You can find the official press release, below. Toyota is issuing three separate recalls covering 1.67 million vehicles worldwide with most of those models in Japan. It looks like the campaigns' impact on the US may be smaller, though. According to Reuters, Toyota isn't aware of any accidents, injuries or fatalities affecting the models. Some yet-unnamed Lexus models might also be affected. The largest of the campaigns does not currently affect any US-market vehicles. About 802,000 units of the Toyota Crown Majesta, Crown, Noah and Voxy in Japan are being repaired to replace a seal that could leak in the brake master cylinder. Those already leaking get a new brake booster, as well, according to Reuters. The only recall currently believed to affect the US is due to a problem covering approximately 759,000 vehicles with 423,000 of them here. The repair is to fix a faulty fuel delivery pipe that could cause a fire if the fuel leaks out. Unfortunately, we don't know which models it covers. Autoblog spoke to Toyota spokesperson Mona Richard and was told the information was still "under embargo." When exactly that embargo will lift isn't yet known, but we're on the case. Finally, Toyota is recalling 190,000 Corolla Rumion and Auris models in Japan for a faulty evaporative emission control unit. Autoblog is in contact with Toyota, and we'll update this story as soon as we know more about its affect on the US market.

Toyota recalls 1.37 million more vehicles for Takata airbags

Toyota is expanding its passenger-side Takata airbag inflator recall campaign by an additional 1.37 million vehicles in the United States. The models covered under this broadened recall are the 2003-2007 Corolla, Matrix, and Lexus SC430; the 2005-2006 Tundra; and the 2005-2007 Sequoia. In total, Toyota says that this expansion brings the number of its vehicles covered under the Takata inflator recall in the US to 2.915 million. For these latest models, owners will be notified by mail soon. The move is similar to a recent decision by Honda to broaden its recall list. As with millions of other vehicles covered under these recalls, it's possible for exposure to moisture to cause the inflator to ignite too quickly in an airbag deployment. This can cause shrapnel to be sprayed at occupants. At least seven deaths have been potentially linked to these ruptures worldwide. TOYOTA EXPANDS TAKATA AIRBAG SAFETY RECALL TORRANCE, Calif., June 16, 2015 – Toyota Motor Sales, USA, Inc. today announced that it is expanding its recalls involving Takata front passenger airbag inflators. Based on recent information from Takata and the National Highway Traffic Safety Administration (NHTSA), Toyota will recall approximately 1,365,000 additional 2003-2007 Corolla and Corolla Matrix; 2005-2006 Tundra; 2005-2007 Sequoia; 2003-2007 Lexus SC430 vehicles. This brings the total number of Toyota and Lexus vehicles covered by Takata recalls in the U.S. to approximately 2,915,000. In the involved vehicles, the front passenger airbag inflators could potentially be susceptible to rupture when deployed and seriously injure vehicle occupants. "Toyota's focus remains on the safety and security of our customers, and we will continue to respond promptly to new developments so we can resolve issues for them as quickly, conveniently and safely as possible," said Dino Triantafyllos, chief quality officer, Toyota Motor North America. Multiple investigations into the root cause of the potential for inflator rupture are taking place, including by Orbital ATK, an independent engineering firm commissioned by an industry-wide joint testing initiative comprised of the ten automotive manufacturers conducting Takata-related recalls. All known owners of the affected Toyota / Lexus vehicles will be notified by first class mail to return their vehicles to a Toyota / Lexus dealer. The dealer will replace the airbag inflator with a newly manufactured one.