2005 Toyota Sienna Le Mini Passenger Van 5-door 3.3l on 2040-cars

Auto blog

NHTSA opens safety investigations into Toyota, GM and Honda crossovers

The National Highway Traffic Safety Administration is evidently keeping itself very busy these days, as the federal agency has just announced it is launching or renewing investigations into Toyota, Honda and General Motors crossovers.
2006-2008 model year Toyota RAV4 crossovers are under review for allegations of rear tie-rod rust which can result in failure. NHTSA also said it is probing some 35 complaints about 2005 Honda Pilot models with inappropriate activation of the vehicles' stability control system. The alleged malfunction can cause the vehicles to slow down or stop in bad unsafe situations. At the moment, NHTSA is reviewing a petition regarding the Pilot issue, a move that will determine whether it needs to open a full-blown investigation.
In addition, Saturn Outlook and GMC Acadia three-row crossovers built in 2007-2009 are getting looked at for "loss of low beam headlamp" function. One complainant said the wiring in his Outlook overheated and melted. NHTSA says it has received 415 complaints about the problem and a GM spokesman confirmed that the automaker already started a "Customer Satisfaction Program" in December to address the issue.

Toyota reveals new TS040 Hybrid LMP1 [w/videos, poll]

There's a new season of motor racing upon us, and while that doesn't always mean a new crop of cars in every series, in the case of the 2014 FIA World Endurance Championship, that's exactly what it means. Porsche recently revealed its new 919 Hybrid and Audi its revised R18 E-Tron Quattro. Now it's Toyota's turn.
Revealed today at the Paul Ricard test track in the South of France, the new TS040 Hybrid is based on the TS030 Hybrid it replaces, redesigned to meet the latest regulations established by the FIA and ACO for the World Endurance Championship and its flagship race, the 24 Hours of Le Mans. In accordance with said regulations, the TS040 is two inches narrower than the TS030 and also incorporates a new hybrid powertrain.
The previous 3.4-liter V8 has been replaced by a 3.7-liter V8 developing 513 horsepower, and the new engine is coupled to an Aisin AW electric motor at the front, a Denso electric motor at the rear and a Nisshinbo super-capacitor that combine to kick out an extra 473 hp, giving the system a combined output of nearly 1,000 horsepower while consuming 25 percent less fuel than last year's car. It also gives the TS040 all-wheel drive to help channel all that power to the road.

Toyota recalling 1.67 million vehicles worldwide in 3 campaigns

Toyota is issuing three separate recalls covering 1.67 million vehicles worldwide with most of those models in Japan. It looks like the campaigns' impact on the US may be smaller, though. According to Reuters, Toyota isn't aware of any accidents, injuries or fatalities affecting the models. Some yet-unnamed Lexus models might also be affected.
The largest of the campaigns does not currently affect any US-market vehicles. About 802,000 units of the Toyota Crown Majesta, Crown, Noah and Voxy in Japan are being repaired to replace a seal that could leak in the brake master cylinder. Those already leaking get a new brake booster, as well, according to Reuters.
The only recall currently believed to affect the US is due to a problem covering approximately 759,000 vehicles with 423,000 of them here. The repair is to fix a faulty fuel delivery pipe that could cause a fire if the fuel leaks out. Unfortunately, we don't know which models it covers. Autoblog spoke to Toyota spokesperson Mona Richard and was told the information was still "under embargo." When exactly that embargo will lift isn't yet known, but we're on the case.