2014 Toyota Rav4 Limited on 2040-cars

Auto blog

Toyota Recalling 1.67 Million Vehicles Worldwide

UPDATE: Toyota is now announcing specifically which models are covered under its fuel pipe recall in the US. The company is repairing about 423,000 Lexus models that include the 2007-2010 LS, 2006-2011 GS, 2006-2011 IS, 2010 IS C and 2008-2010 IS-F. The automaker says that it isn't aware of any fires, crashes, injuries or fatalities caused by this problem. According to Toyota, the recall is because it's possible for the fuel delivery pipes and the fuel pressure sensor to form a bad seal with the gasket between them because of a protective coating protecting against corrosion on the pipes. It's possible for this to eventually cause a fuel leak, and obviously in a hot engine bay that's a potential fire risk. To fix the problem, dealers will replace the gasket and repair the gasket seating surface between the fuel delivery pipe and the fuel pressure sensor. The company will begin notifying owners soon. You can find the official press release, below. Toyota is issuing three separate recalls covering 1.67 million vehicles worldwide with most of those models in Japan. It looks like the campaigns' impact on the US may be smaller, though. According to Reuters, Toyota isn't aware of any accidents, injuries or fatalities affecting the models. Some yet-unnamed Lexus models might also be affected. The largest of the campaigns does not currently affect any US-market vehicles. About 802,000 units of the Toyota Crown Majesta, Crown, Noah and Voxy in Japan are being repaired to replace a seal that could leak in the brake master cylinder. Those already leaking get a new brake booster, as well, according to Reuters. The only recall currently believed to affect the US is due to a problem covering approximately 759,000 vehicles with 423,000 of them here. The repair is to fix a faulty fuel delivery pipe that could cause a fire if the fuel leaks out. Unfortunately, we don't know which models it covers. Autoblog spoke to Toyota spokesperson Mona Richard and was told the information was still "under embargo." When exactly that embargo will lift isn't yet known, but we're on the case. Finally, Toyota is recalling 190,000 Corolla Rumion and Auris models in Japan for a faulty evaporative emission control unit. Autoblog is in contact with Toyota, and we'll update this story as soon as we know more about its affect on the US market.

J.D. Power: Vehicle dependability at all-time high, Lexus and Porsche lead

Each year, J.D. Power and Associates surveys original owners of three-year-old vehicles to find out what kinds of problems they have had experienced over the last 12 months, and then it uses this data to create its annual Vehicle Dependability Study. This means that the models in the 2013 study are 2010 model year vehicles, and J.D. Power rates each make as well as the top individual models based on how many problems were experienced per 100 vehicles (PP100).
Debunking the idea that carryover models are more dependable than new or updated models, the 2013 study found that the average carryover model experienced 133 PP100, while all-new or redesigned vehicles for the 2010 model year had 116 PP100; vehicles that received minor changes fared the best with just 111 PP100. The overall average for all makes was 126 PP100, which is the lowest figure since the findings were first issued in 1989.

Japanese automakers ramping production for renewed American sales

The 2011 earthquake and tsunami that struck Japan took quite the toll on the automotive industry in that nation. Not content to lean on that tragedy as excuse for slagging sales, the Japanese automakers are planning on a major production expansion in North America. The aim is to reclaim the market share lost from the Tsunami-based dip, and overcome a dollar/yen exchange rate that makes exporting to America unprofitable.
Following the Tsunami, Japanese automakers ramped up production in their North American facilities to compensate, but according to Automotive News, Nissan, Honda and others have all reported plans for still-further increased production in the year ahead. As part of this ramp-up, Mazda will open a facility in Salamnca, Mexico before March of 2014. Part of that increase in output is 50,000 units of a Toyota-badged compact car, which Mazda will produce.
Other Mexican production facilities opening include a Honda plant, which will open in Spring 2014 in Celaya, and a Nissan plant, set to open later this year in Aguascalientes. Nissan also said that it will need another plant in North America within the next five years. According to Nissan Boss Carlos Ghosn, the company aims to raise its stake in the US market from 8 percent to 10, and adding production will help achieve that goal. Even Mitsubishi is aiming to boost production at its Normal, Illinois plant. Production of the Outlander Sport is currently at 50,000, which Mitsubishi wants to raise to 70,000.