2010 Red I! on 2040-cars

Auto blog

Subaru Indiana plant to stop building Toyota Camry

Subaru may be set to end production of the Toyota Camry at its Lafayette, IN facility by 2017, according to a report from the Louisville Journal-Courier and a CBS affiliate in Columbia, South Carolina. Speaking to the plant's Executive Vice President Tom Easterday, the whole affair sounds like a done deal.
"Based on changes in Toyota's production plans, they have decided that the award-winning Camry production contract will not be renewed," Easterday said. Easterday was quick to emphasize that just because Camry production would end, doesn't mean jobs will be lost. "There will be no loss of jobs at SIA as a result of this," he said, before adding that the loss of Camry production will have no impact Subaru's $400 million investment to ready the plant for Impreza production in 2016. That said, adding a promised 900 jobs may take longer than originally planned, as Camry production staff are set to be retrained on Subaru production.
SIA currently has the capacity to produce 100,000 Camrys per year, and began production of the family sedan in 2007 alongside production of the Subaru Outback, Legacy and eventually, the soon-to-be-discontinued Tribeca.

Japan plans real-world diesel emissions test after companies fail

Japan's transport ministry plans to start real-world diesel emissions tests after an experiment found four models from Toyota, Nissan, and Mitsubishi that produced more nitrogen oxide (NOx) emissions than the nation's rules allow, according to The Japan Times. Regulators there usually only perform emissions checks in the lab. The VW diesel scandal has everyone double-checking their figures. Diesel versions of the Toyota Hiace van, Land Cruiser Prado, and Nissan X-Trail produced up to 10 times more NOx than allowed. The Mitsubishi Delica D:5 was up to five times over the limit, The Wall Street Journal reports. There was no evidence of defeat devices in the vehicles. Mazda performed well in the experiment, though. The CX-5 passed with nearly the same results on the road and in the lab. The Demio, better known as the Mazda2, did nearly as well with only slighter higher figures in the real world than in the controlled setting. The experimenters theorized the reason for the excessive emissions was that cold weather caused the engines' software to shut off the exhaust gas recirculation to prevent damage, according to the WSJ. However, this behavior also increased NOx production. Toyota, Nissan, and Mitsubishi don't have to worry about punishment from the transport ministry because this check was just an experiment. Their models already passed the mandated lab tests, which was the only requirement, according to The Japan Times. As governments begin greater real-world emissions tests, the results suggests diesels aren't very clean. A recent check in France found models from Ford, Renault, and Mercedes-Benz that didn't perform up to the standards. Regulators in India conducted similar evaluations and ordered VW to recall over 300,000 vehicles. Related Video:

Toyota says freezing temps pose zero problems for fuel cell vehicles

Hydrogen-powered fuel cell electric vehicles are not afraid of one thing – freezing cold weather. That's the latest from two companies that have been driving the cars in frostbite temperatures in the Northeast recently. Proton Onsite runs a fleet of 10 Toyota FCHV-adv fuel cell vehicles out of its Connecticut headquarters and discovered that the snow and three-degree temperature didn't restrict range. Mark Schiller, Proton vice president of business development, said in a statement that, "I went out to my Toyota FCHV-adv and brushed off a foot of snow before starting the car right up. No problem." While electric vehicles can have their driving range reduced in extreme temperatures (but not always), Proton Onsite hasn't seen that happen in the Polar Vortex. They're performing flawlessly in freezing temperatures even with the heaters blasting, and are continuing to hit their range of about 300 miles, Schiller said. Air Products, based on Allentown, PA, has had a similar experience. The FCHV-adv has had great performance under harsh conditions, according to Nick Mittica, commercial manager, hydrogen energy systems. Employees drove the fuel cell vehicle during one of Pennsylvania's worst winters in recent memory and, you guessed it, "No problem." Toyota says that has put its fuel cell fleet through the wringer, logging millions of miles over the last decade, to make sure performance can be delivered within extreme weather conditions. Toyota engineers spent weeks testing cold weather start up, performance and durability up in Yellowknife, Canada. Temperature can reach -30 degrees Celsius (-22 degrees Fahrenheit) at that location. On other end of the scale, Toyota was able to verify that its FCVs can handle driving through heat in Death Valley national park. We heard the same from Mercedes the other day, too. Extreme weather functionality is apparently something automakers want to make absolutely sure the public doesn't worry about. Jan. 30, 2014 – Record low temperatures have stranded many East Coast drivers, but not those driving a Toyota fuel cell hybrid vehicle. Connecticut-based Proton Onsite, which operates a fleet of ten Toyota FCHV-adv fuel cell vehicles, says that even in single digit temperatures, the FCHV-adv shows no signs of frostbite. "We had another snow storm Tuesday night and this morning the temperature was 3 degrees," says Mark Schiller, Proton vice president of business development.