2001 Toyota Mr2 Spyder on 2040-cars

Auto blog

Toyota Recalling 1.67 Million Vehicles Worldwide

UPDATE: Toyota is now announcing specifically which models are covered under its fuel pipe recall in the US. The company is repairing about 423,000 Lexus models that include the 2007-2010 LS, 2006-2011 GS, 2006-2011 IS, 2010 IS C and 2008-2010 IS-F. The automaker says that it isn't aware of any fires, crashes, injuries or fatalities caused by this problem. According to Toyota, the recall is because it's possible for the fuel delivery pipes and the fuel pressure sensor to form a bad seal with the gasket between them because of a protective coating protecting against corrosion on the pipes. It's possible for this to eventually cause a fuel leak, and obviously in a hot engine bay that's a potential fire risk. To fix the problem, dealers will replace the gasket and repair the gasket seating surface between the fuel delivery pipe and the fuel pressure sensor. The company will begin notifying owners soon. You can find the official press release, below. Toyota is issuing three separate recalls covering 1.67 million vehicles worldwide with most of those models in Japan. It looks like the campaigns' impact on the US may be smaller, though. According to Reuters, Toyota isn't aware of any accidents, injuries or fatalities affecting the models. Some yet-unnamed Lexus models might also be affected. The largest of the campaigns does not currently affect any US-market vehicles. About 802,000 units of the Toyota Crown Majesta, Crown, Noah and Voxy in Japan are being repaired to replace a seal that could leak in the brake master cylinder. Those already leaking get a new brake booster, as well, according to Reuters. The only recall currently believed to affect the US is due to a problem covering approximately 759,000 vehicles with 423,000 of them here. The repair is to fix a faulty fuel delivery pipe that could cause a fire if the fuel leaks out. Unfortunately, we don't know which models it covers. Autoblog spoke to Toyota spokesperson Mona Richard and was told the information was still "under embargo." When exactly that embargo will lift isn't yet known, but we're on the case. Finally, Toyota is recalling 190,000 Corolla Rumion and Auris models in Japan for a faulty evaporative emission control unit. Autoblog is in contact with Toyota, and we'll update this story as soon as we know more about its affect on the US market.

Recharge Wrap-up: Toyota HQ goes solar, CARB fights methane

Opel denies allegations about illegal emissions software as the German transport ministry begins its review. Opel has turned documents over to German authorities, and promises to hold a "constructive dialogue" while answering any lingering questions, says the automaker. Opel says that "the allegations reflect a wrong understanding of how diesel engines work." As German magazine Der Spiegel renewed questions about a cheat device similar to those used by Volkswagen, Opel reiterates, "We do not have any software that recognizes whether a vehicle is undergoing an exhaust emissions test." Read more at Automotive News Europe. South Korean President Park Geun-hye suggests that Seoul and Paris work together on the promotion of fuel cell technology. French industrial gases company Air Liquide manufactures liquid hydrogen, while Korean automaker Hyundai has already deployed its Tucson Fuel Cell crossover in select markets around the world. The two companies have signed a deal to cooperate on hydrogen technology. President Park visited an Air Liquide research center during a trip to Europe, where she said that a partnership between Hyundai and Air Liquide can help their countries stay ahead in the fuel cell vehicle market. Read more from Green Car Congress. CARB is proposing new rules for oil and gas facilities that would reduce methane emissions by more than 50 percent. The system, treatment, operation, and device standards would apply to onshore and offshore oil and gas production, storage, processing, and transmission facilities, covering procedures for leak detection and repair, equipment replacement, record keeping, and data reporting. "Methane emissions from the oil and gas industry contribute to California's [greenhouse gas] emissions and cost-effective reduction opportunities already exist and are available for use in the sector," CARB says. "In addition, reducing methane emissions from this sector will help slow the rate of climate change in the near-term and have an immediate beneficial impact on climate change." A hearing is scheduled for July 21 to discuss the proposal. Read more from SNL. Toyota's new Plano, Texas campus will get 25 percent of its energy from the sun. As Toyota plans to move into its new North American headquarters next year, it is building a 7.75-megawatt solar system to provide renewable energy for its operations. The solar arrays will be built atop three parking structures by the end of 2017.

Airbag recall adds 85k Pontiac Vibes to tally

The repairs needed for the faulty airbag inflators supplied by Takata continue to expand. Toyota initially announced a recall of 766,300 vehicles equipped with the bad part on June 11 as a followup to a campaign from 2013. Soon after, the National Highway Traffic Safety Administration opened a preliminary evaluation into five automakers who also used the component in their models. Now, NHTSA has released the official announcement of the latest Toyota recall listing 844,277 affected cars, including the newly added 2003-2004 Pontiac Vibe.
While NHTSA's document didn't include a model-by-model breakdown, General Motors spokesperson Alan Adler estimated to Autoblog that roughly 85,000 Vibes in the US would be covered under the latest recall. Like the rest of the affected models, the airbag inflator could rupture in a crash causing the bag not to work correctly, possibly spraying metal fragments at the occupant.
Toyota spokesperson Cindy Knight told Autoblog that the reason for the disparity between the earlier press release and NHTSA document was that Toyota was continuing to comb through VINs to create a list of affected vehicles. The original number was an estimate of that process at the time. Scroll down to the recall report from NHTSA.