Auto blog

Toyota R&D shows off free piston engine linear generator for future EVs

We often hear how an electric vehicle powertrain architecture allows vehicle designers much more freedom than a traditional ICE powertrain does. With differently shaped battery modules and small electric motors, there are lots of way to put the pieces together. With today's plug-in hybrid technology, engineers still need to put a decent-sized ICE somewhere, but new technology from Toyota could free up the gas-electric vehicle designers of the future. Presented at the recent SAE World Congress in Detroit, the idea from Toyota Central R&D Labs Inc. and involves what is called a Free Piston Engine Linear Generator (FPEG). Think of it as a sort of one-cylinder, two-stroke mini-engine that can work either as a generator (thank to magnets and a linear coil) or to directly drive a vehicle. The current prototype is a 10-kW unit that Toyota say would provide enough power to get a B- or C-segment electric vehicle up to highway speeds (75 miles per hour) when paired up to offer 20 kW. Pairing the FPEGs is also important to minimize vibrations. One system tested by Toyota had a 42 percent thermal efficiency, but the engineers are working to improve the overall efficiency even further. You can watch an animated video of the piston in action here (click on "Outline") and see the SAE papers here and here. More technical details are available at Green Car Congress. News Source: Toyota Labs via Green Car CongressTip: Thanks, Joe V. Green Misc. Auto Shows Toyota Technology Emerging Technologies Electric generator

Japan plans real-world diesel emissions test after companies fail

Japan's transport ministry plans to start real-world diesel emissions tests after an experiment found four models from Toyota, Nissan, and Mitsubishi that produced more nitrogen oxide (NOx) emissions than the nation's rules allow, according to The Japan Times. Regulators there usually only perform emissions checks in the lab. The VW diesel scandal has everyone double-checking their figures. Diesel versions of the Toyota Hiace van, Land Cruiser Prado, and Nissan X-Trail produced up to 10 times more NOx than allowed. The Mitsubishi Delica D:5 was up to five times over the limit, The Wall Street Journal reports. There was no evidence of defeat devices in the vehicles. Mazda performed well in the experiment, though. The CX-5 passed with nearly the same results on the road and in the lab. The Demio, better known as the Mazda2, did nearly as well with only slighter higher figures in the real world than in the controlled setting. The experimenters theorized the reason for the excessive emissions was that cold weather caused the engines' software to shut off the exhaust gas recirculation to prevent damage, according to the WSJ. However, this behavior also increased NOx production. Toyota, Nissan, and Mitsubishi don't have to worry about punishment from the transport ministry because this check was just an experiment. Their models already passed the mandated lab tests, which was the only requirement, according to The Japan Times. As governments begin greater real-world emissions tests, the results suggests diesels aren't very clean. A recent check in France found models from Ford, Renault, and Mercedes-Benz that didn't perform up to the standards. Regulators in India conducted similar evaluations and ordered VW to recall over 300,000 vehicles. Related Video:

Recharge Wrap-up: BMW plans for retired batteries; automakers support dual-standard chargers

Toyota will test hybrids with silicon-carbide (SiC) power semiconductors. In Japan, Toyota has put the SiC power semiconductors into the power control units of a Camry Hybrid prototype and a fuel cell bus for a year-long test. Research suggests the SiC units will decrease electrical losses while managing power supply, thus improving overall powertrain efficiency. Current power semiconductors account for about 20 percent of electrical losses, and success with these tests could mean more efficient hybrids on the roads in the future. Read more at Hybrid Cars. Automakers from CCS and CHAdeMO camps are supporting dual-standard charging station networks. https://www.autoblog.com/bmw/, Volkswagen (CCS camp) and ChargePoint announced plans to build "express charging corridors" by installing about 100 DC fast chargers, many of which will support both types of charging. Kansas City Power & Light is partnering with Nissan (CHAdeMO camp) and ChargePoint to install DC chargers that "will charge any model of electric vehicle on the market." This leads the folks at Green Car Reports to look into whether this ends the looming standard war between automakers in the US. Read more at Green Car Reports. BMW, Bosch and utility company Vattenfall are making plans for a second life for retired BMW i3 batteries. The Second Life Batteries Alliance project will recycle the old lithium ion battery packs - which can still hold a charge - in off-grid storage and grid-stabilization applications, beginning with a grid storage system in Hamburg, Germany. Bosch has created a battery management algorithm to extend the life of the batteries and make sure they don't cause harm to Vattenfall's facilities. Read more at Transport Evolved.