2007 Toyota Camry Le Cruise Control One Owner 66k Miles Texas Direct Auto on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

EPA says automakers ahead of schedule for 54.5 MPG by 2025

Remember, the target is 54.5 miles per gallon by 2025. Today, the CAFE level is a little over 30. How we get from here to there is something the US Environmental Protection Agency (EPA) is monitoring closely. Thus, the EPA just released an annual flash report on how the auto industry is progressing towards meeting the nation's fuel economy goals. Overall, the industry is doing almost 10 grams per mile (equivalent) better than the rules require. The good news is that the industry is a bit ahead of schedule. In the report (see page iii), the EPA breaks things down by automaker based only on MY12 numbers. Tesla is at the top of the list (which is ranked by over-compliance with 2012MY CO2 standards), but for our money, the real leader is Toyota. The Japanese automaker built the second-highest number of vehicles (2,020,248, after General Motors' 2,364,374) but racked up the most net 2012 over-compliance credits (13,163,009 metric tons). That's an average of over 6.5 metric tons per vehicle. The next closest is Honda, with just over five metric tons of credits per vehicle. Given the MPG fiasco with Hyundai and Kia, the EPA says, "we are excluding Hyundai and Kia data because of the ongoing investigation into their testing methods," but overall, the rest of the industry has credits worth 25,053,168 metric tons of CO2, which means it's doing almost 10 grams per mile (equivalent) better than the rules require. Go team. For now, the numbers in this report (and there are a lot more of them – get the 59-page PDF for yourself here), can't really be used to understand everything from the first year of the new CAFE program. The EPA writes, "Because the program allows credits and deficits to be carried into future years, at the close of the 2012 model year no manufacturer is considered to be out of compliance with the program. ... Compliance with the 2012 model year standards can't be fully assessed until the end of the 2015 model year." There are a more interesting tidbits in the report, such as the fact that Fisker produced 1,415 model year 2012 vehicles, Tesla made 2,952. Remember, too, that CAFE numbers don't equal the fuel economy you see in your daily drives. In the real world, the 54.5 CAFE level will be about 40 mpg, and the average fuel economy today is around 25 mpg, so we have a ways to go, no matter how you measure it. EPA Report: Data Show Automakers on Track in meeting Greenhouse Gas Standards WASHINGTON – Today, the U.S.

Stellantis and Toyota expand partnership with large commercial van

Stellantis said on Monday it would expand its partnership with Toyota Motor Europe (TME) with a new large commercial van, including an electric version. Stellantis will supply TME, a unit of Japan's Toyota Motor Corp, with the new vehicle for sale in Europe under the Toyota brand, it said. The van will be produced at Stellantis plants in Gliwice, Poland, and Atessa, Italy. "Planned for mid-2024, the new large-size commercial van marks TME's first entry into the large-size commercial vehicle segment," Stellantis added in a statement. The deal widens the partnership between the two companies and allows a better optimization of Stellantis' Atessa plant, which currently makes large vans sold under the Peugeot, Citroen and Fiat marques. "It represents an important addition and completes our light commercial line-up for Toyota's European customers," Stellantis said. Paris-listed shares in Stellantis were up 1.6% by 0941 GMT. Carmakers have increasingly been agreeing cross-manufacturing deals to reduce costs in vans, which due to a boom in parcel delivery are seeing large demand — and where electric vehicle versions are also seeing rising sales to carry out "last-mile" deliveries in city centers. Green Fiat Toyota Citroen Peugeot Minivan/Van Commercial Vehicles Electric