2003 Toyota Camry Fwd Cdcassetteplayer Cruisecontrol Keylessentry We Finance!! on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Toyota 86 most likely to get more power through more displacement? [w/poll]

The Sydney Morning Herald has spoken to Tetsuya Tada, chief engineer of the Toyota 86 (our version of it, the Scion FR-S, is pictured above), and they've been promised that more power is on the way. We've heard a lot of speculation about a more powerful Toyobaru since before the standard model was even launched. The only question now is how the power will be delivered, and among the engine concepts we've already heard about - turbo, supercharger, twin-charged, hybrid - is a new one: more displacement.
Tada said that an engine with more displacement than the current coupe's 2.0 liters is being tested alongside a turbocharged and a hybrid-assisted motor. The SMH cites "inside sources" as saying the displacement option is the one likely to get the go-ahead, and suggests increased bore and stroke will see the engine grow to 2.5 liters, horsepower to about 250 - a 50-hp increase over the present car.
While that's apparently the betting man's solution for the long-awaited increase in gumption, what happens with the next generation could be more wide open than we suspected. According to the report, Tada "hinted that [a successor] could be a radically different car, potentially dropping the boxer engine altogether." He said once they've sorted out the concept for the second generation car, then they'll sort out an engine. That's where a turbo option could come to market, perhaps the turbocharged four-cylinder Toyota is developing for the Lexus NX crossover or a hybrid system that uses a capacitor.

Recharge Wrap-up: Toyota Prius airbag recall, Peugeot launches eU01s e-bike

Toyota is recalling 7,600 Prius vehicles for an airbag issue. Certain examples of the 2016 Prius could have malfunctioning inflators that could cause the passenger side airbags to deploy accidentally. There are no known injuries from the faulty airbags, but Toyota says, "This has been observed when the vehicle is parked and unoccupied for a period of time." Toyota also says this issue is unrelated to the massive recall of airbags supplied by Takata. The automaker will contact affected owners to arrange free repairs. Read more at Automotive News. Peugeot is adding another e-bike to its portfolio with the eU01s. What sets this electrically assisted bicycle apart from both regular bikes and other pedelecs is its ability to propel the bike to 28 mph under electric power. It comes with either a 400- or 500-Wh lithium-ion battery, providing 47 or 59 miles of range, respectively. It also offers an optional on-board computer with its 4.3-inch screen, through which riders can customize the electric assistance, get directions, receive sports coaching, and connect their smartphone. Earlier this year, Peugeot also launched its e-Kick scooter and folding eF01 e-bike. Read more at Green Car Congress. BYD is expanding its manufacturing facility in the US. In the second of three phases for the plant, BYD is adding onto its factory in Lancaster, California, where it currently builds electric buses. The Chinese company plans to triple the number of employees, up from the current 400, as it expands the facility by 40,000 square feet. BYD plans to build medium- and heavy-duty trucks at the plant, but declined to comment on whether it has plans to build light-duty vehicles there. Read more at Automotive News. The German states of Hesse and Baden-Wuerttemberg are suing Volkswagen over the Dieselgate scandal. The states are joining other investors seeking damages over losses incurred because of the automaker's emissions cheat device. Hesse Finance Minister Thomas Schaefer said the scandal cost the state about $4.4 million in stock losses, while Baden-Wuerttemberg likely lost closer to $450,000. Bavaria said earlier that it would sue Volkswagen on behalf of its pension fund for civil servants, which lost around $780,000. Read more from Automotive News Europe.