2000 Toyota 4runner 4dr Sr5 3.4l 4wd Sr5 Leather 5speed Manual 1owner Low Miles on 2040-cars

Auto blog

Toyota's Bob Carter says seat heater stop-sale due to inconsequential compliance error

Last week, Toyota let it be known that a number of its more-popular vehicles were subject to a "stop-sale" order due to faulty seat heaters on these vehicles. No injuries were reported, but the problem affected a lot of models, including the 2013 and 2014 Camry, Camry Hybrid, Avalon, Avalon Hybrid, Sienna, Corolla, Tacoma and Tundra. Toyota originally said 50,000 vehicles were involved, but Bob Carter, senior vice president of automotive operations for Toyota Motor Sales, knocked that down to 30,000 during an interview at the Chicago Auto Show this week and said that the problem is not going to have a big impact on Toyota's sales. "It's an important situation but it will have a very minor impact on February sales," he told AutoblogGreen. "Dealers will start receiving new heating elements this week and then we have a process to take out the heating element that was put in and exchange that for the new fabric. It's very simple. It's a quick repair." Quick in this situation means about three hours to swap out the heating elements in two seats, according to Toyota's John Hanson. Since the Avalon also has heated rear seats, that car will require a total of six hours in the shop. Hanson said there was no official timeline for when the exchange program would be completed, "but new vehicles are arriving at some dealerships with the new seat heaters already installed." With a fix already in place, Carter would not comment on whether a recall is likely, saying only, "I'm not the expert on that. We're working with the NHTSA and ultimately it's their decision. We believe it's an inconsequential compliance error that was made by one of our suppliers and we're going to correct it." Featured Gallery 2013 Toyota Camry Hybrid: Review View 23 Photos News Source: Toyota Green Chicago Auto Show Toyota AutoblogGreen Exclusive Hybrid camry hybrid bob carter

Recharge Wrap-up: Honda Grace hybrid goes on sale in Japan, Daimler spends 100M euros on batteries

The Mercedes-Benz S-500 Plug-In Hybrid has earned an Environmental Certificate from the TUV Sud technical inspection authority. The award is based on a lifecycle assessment of the vehicle. This includes the ability to reduce CO2 emissions by 43 percent through charging, and by 56 percent if charged using hydroelectricity. Read more in the press release below. Daimler is expanding its production capacity for lithium-ion batteries. The company is investing around 100 million euros in its subsidiary Deutsche ACCUmotive, who will provide batteries for the electric Smart Fortwo and Forfour, as well as various Mercedes-Benz models. By the end of the construction, Deutsche ACCUmotive will have quadrupled production and logistics space since 2011. Read more in the press release below. Honda has begun sales of its Grace hybrid sedan in Japan. The Grace is based on the Honda Fit and uses the automaker's Sport Hybrid i-DCD system. It comes in front- and four-wheel-drive versions and uses a seven-speed DCT with built-in motor. The Honda Grace starts at the equivalent of about $16,500. Read more in the press release below. Honda has begun operation of its wind farm in Brazil. The farm consists of nine wind turbines, expected to produce about 95,000 MWh of electricity per year, which is on par with Honda's consumption for automobile production in the country. Honda is aiming to cut its CO2 production by 30 percent by 2020 compared to 2000 levels. Read more in the press release below. Toyota has won the 2014 World Endurance Championship's Driver and Manufacturer categories with hybrid technology. Toyota celebrated the win after the final race in Sao Paolo, Brazil. Toyota uses the same hybrid technology in its racing cars as it does in its production vehicles. Read more in the press release below. Controlled Power Technologies and other groups are calling for an international 48-volt electrical standard for vehicles. The groups called for the standard at the International Conference Automotive 48 V Power Supply Systems, saying that the 48V standard for mild hybrids would help make the systems more affordable. This will make it easier for automakers to meet the more stringent CO2 standards anticipated in coming years along with the introduction of the World Light vehicles Test Procedures. Read more at Green Car Congress. The world's first certified three-litre luxury saloon: S 500 PLUG-IN HYBRID receives Environmental Certificate Stuttgart.

Toyota temporarily idles pair of Indian plants due to labor unrest

The Detroit News reported today that Toyota will restart production at two Indian plants, following a shutdown on Monday.
Factory labor, management and police in Asia engage in the kind of violent altercations that we're not used to, having almost entirely walked away from the overtly brutal relations epitomized by the Pinkerton Detective Agency and the Flint Sit-Down Strike. In India, a plant owned by a Ford transmission supplier plant was shut down in 2009 after incidents between workers and armed men around the same time as Ssangyong workers occupied a factory in South Korea, in 2012 Suzuki Maruti workers rioted over wages around the same time upset employees beat a ceramics factory president to death in retaliation for a labor leader's killing.
Toyota is the latest to company trying to avoid that road. The Detroit Free Press reported earlier this week that it shut down two plants in India after 11 months of acrimonious wage negotiations and arbitration have gone nowhere. Toyota said the plant workers in Bidadi, near Bangalore, had deliberately stopped production at times over the past 45 days and threatened management. The workers said they wanted their wages raised by an amount already agreed to by management, but that management had reneged; news reports weren't clear on the amount, some saying nearly 10,000 rupees ($165 US) more per month, another saying 4,000 rupees ($65 US), but reports agree that Toyota has said it will only go as high as 3,050 rupees ($50 US).