2004 Saturn Vue Base Sport Utility 4-door 3.5l on 2040-cars

Auto blog

Saturn Vue ignition issue was discussed three times before recall, new documents reveal

Despite the tens of millions of recalled vehicles this year, it's somewhat rare that we get a glimpse into what goes into deciding when to conduct one of these safety campaigns. New documents published by General Motors and the National Highway Traffic Safety Administration are giving us an interesting opportunity to see how the sausage is made and show the number of meetings it takes to declare a recall.
In early August, GM added about another 269,000 vehicles to its 2014 recall tally in the US when it announced a slew of new safety campaigns. Among them was a fix for the 2002-2004 Saturn Vue that covered 202,155 of them in the US. The problem was that the key could be removed from the ignition even when it wasn't in the "OFF" position, and that had caused two crashes and one injury, according to the automaker.
Where we start to see behind the veil is in the defect notice freshly released by NHTSA. It shows that GM began investigating more widely for ignition switches in April, shortly after the company expanded its ignition switch recall to a variety of Saturn products, among others, according to Automotive News. The automaker found 152 reports in the 2002-2004 Vue of vehicles rolling away or the key being removed out of a total population of 215,243 units worldwide.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

A chopped-up General Motors EV1 shell sold for $23,662

Despite not having a VIN, a powertrain, a frame, or any doors, a decrepit General Motors EV1 shell recently sold for $23,662.10 on govdeals.com. Sold by the University of Cincinnati, the car — or what remains of it — is headed to an electric vehicle collection called The Beata Electric Motor Carriage Collection. Technically, the GM EV1 was the first mass-produced and purposed-built electric car in America. When it was released in 1996 for the 1997 model year, however, GM strictly leased the car as part of a "real-world engineering evaluation." The limited production run was meant to test real life with an EV and judge the interest from the public. GM only built 1,117 units, all of which were recalled, and most of them ultimately were sent to the crusher. But a select few were stripped of their powertrains and donated to universities and museums for educational purposes. One of those non-functioning cars made it to the University of Cincinnati in 2008. The post says it "has been in storage since," but it's not clear if the car sat in storage untouched or was stored and used by the university. According to EpiclyEpicEthan1, who posted the sales listing to r/cars, the car was purchased by The Beata Electric Motor Carriage Collection in Colorado. The Beata (derived from the Latin word for blessed) collection is a gathering of '90s OEM electric vehicles and a general EV hub. The website says the vehicles are used for testing, diagnostics, education, events, and overall preservation and documentation. The rare and niche collection also includes a 1993 Dodge/Chrysler TEVan, a 1997 Honda EV Plus, a 1999 Dodge/Chrysler EPIC EV, a 1998 Ford Ranger EV, a 2002 Toyota RAV4 EV LongRanger III, a Tesla Roadster, a 1998 Nissan Altra EV, a 1998 Chevrolet S-10 EV, a 2011 Nissan Leaf, and a 2012 Tesla Model S. Beata also has several other projects under construction such as the 2000 Toyota RXT-G Prototype, a 1997 RAV4 coupe EV prototype, the 1995 AC Propulsion eCivic EV, a 1995 ACP RXT-G Prototype LongRanger II, a 1995 ACP RXT-G Prototype LongRanger I, and a GM EV1. Beata acts as a resource for EV1 owners and helps place parts it finds and doesn't need. The parts it does need are put into building a working EV1. Beata's current EV1, which is 80 percent complete, is made up from more than 50 different parts sources, including from all three versions of the EV1, the 1994 LPF4 PreView "Impact" series, the 1997 EV1, and the 1999 EV1.