2000 Saturn S Series on 2040-cars

Auto blog

Junkyard Gem: 2004 Saturn Vue with manual transmission

GM's Saturn Division has been gone since the final 2010 Auras, Outlooks, Skies, and Vues slunk apologetically out of the showrooms, and I'm doing my best to document the more interesting models from The General's once-revolutionary brand. Some of the later Saturns began life as Opel designs, but the Vue actually was the first vehicle to go on the all-new GM Theta platform; the Opel Antara was thus a Saturn copy, a fact that Saturn fans no doubt trot out when they get shamed by Opel zealots over the Astra. Today's Junkyard Gem is a most unusual Vue, in the sense that its original purchaser was fine with both the base manual transmission and the leather-upholstery upgrade. Sure, the cheapest way to buy a new Vue— which was sold here for the 2002-2007 model years— was to get it with the base transmission: a five-speed manual. You can still buy a new car with a five-on-the-floor manual right now, but only in a handful of cheapmobiles; by the middle 2000s, a tiny-and-ever-shrinking subset of American car shoppers would even consider a three-pedal commuter vehicle. Really, there were only two reasons an American new-car buyer would have considered a non-enthusiast vehicle with a manual transmission in 2004: either an eccentric preference for the good ol' stickshift or just plain penny-pinching. The cheapest possible '04 Vue was the version with four-cylinder 2.2-liter engine, front-wheel-drive, and five-speed manual transmission, and it started at $17,025 (about $26,080 in 2022 dollars). That's what we're looking at here. The optional CVT automatic transmission cost an additional $2,095 ($3,210 today), so it made sense to get the manual if you wanted to save serious money on your Vue. However, this car is loaded to the gunwales with nice equipment upgrades, to the tune of at least the Leather Appointments Package ($755) and the Sports Plus II Package ($1,300) and probably a lot more.  So, a buyer who didn't care about power (so no V6 engine), didn't want all-wheel-drive, liked driving a manual transmission Â… but insisted on power everything and a full-zoot comfy leather interior Â… in a cheap small SUV sold by a fast-fading brand. The conversations with the Saturn salesmen about this thing must have been interesting. Built in Tennessee, sold new in Denver, will be crushed near Pikes Peak.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

Recalled Saturn Ion facing separate federal safety probe

General Motors may be staring down another recall campaign for one of its models already embroiled in its high-profile ignition recall. The 2003-2007 Saturn Ion is already among the 1.6-million vehicles being recalled for faulty ignition switches, and now new light is being shed on a National Highway Traffic Safety Administration investigation over 2004-2007 models centering on a loss of power steering.
The government safety regulator has received 846 complaints about the problem and claims that GM has had 3,489 reports of failure. Of those cases, there have been 16 accidents and 2 injuries reported, according to Automotive News. While NHTSA has been conducting an investigation since September 2011, no recall has been issued yet.
The inquiry's length was brought to light by an organization called the National Legal and Policy Center that alleges GM and NHTSA have known about the problem but are delaying a recall. It has sent a letter to CEO Mary Barra asking "to recall Saturn Ions for the model years 2004 through 2007 without further delay." The letter in question is available in full on the group's website.