Xr Suv 3.6l on 2040-cars

Auto blog

GM expands ignition switch recall to over 1.3 million cars amid climbing death toll

588,000 Saturn Sky, Saturn Ion, Pontiac Solstice and Chevy HHR models join the 778,000 cars already being recalled.
General Motors has announced a massive expansion of a 778,000-unit recall we told you about two weeks ago, doubling not only the total number of cars affected but expanding the recall beyond Chevrolet Cobalt and Pontiac G5 models previously mentioned. The recall originally centered around ignition switches that could slip out of the "run" position if jostled or if any weight was applied to the key in the cylinder.

NHTSA opens safety investigations into Toyota, GM and Honda crossovers

The National Highway Traffic Safety Administration is evidently keeping itself very busy these days, as the federal agency has just announced it is launching or renewing investigations into Toyota, Honda and General Motors crossovers.
2006-2008 model year Toyota RAV4 crossovers are under review for allegations of rear tie-rod rust which can result in failure. NHTSA also said it is probing some 35 complaints about 2005 Honda Pilot models with inappropriate activation of the vehicles' stability control system. The alleged malfunction can cause the vehicles to slow down or stop in bad unsafe situations. At the moment, NHTSA is reviewing a petition regarding the Pilot issue, a move that will determine whether it needs to open a full-blown investigation.
In addition, Saturn Outlook and GMC Acadia three-row crossovers built in 2007-2009 are getting looked at for "loss of low beam headlamp" function. One complainant said the wiring in his Outlook overheated and melted. NHTSA says it has received 415 complaints about the problem and a GM spokesman confirmed that the automaker already started a "Customer Satisfaction Program" in December to address the issue.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.