2001 Saturn Sl 1 on 2040-cars

Auto blog

Saturn Vue ignition issue was discussed three times before recall, new documents reveal

Despite the tens of millions of recalled vehicles this year, it's somewhat rare that we get a glimpse into what goes into deciding when to conduct one of these safety campaigns. New documents published by General Motors and the National Highway Traffic Safety Administration are giving us an interesting opportunity to see how the sausage is made and show the number of meetings it takes to declare a recall.
In early August, GM added about another 269,000 vehicles to its 2014 recall tally in the US when it announced a slew of new safety campaigns. Among them was a fix for the 2002-2004 Saturn Vue that covered 202,155 of them in the US. The problem was that the key could be removed from the ignition even when it wasn't in the "OFF" position, and that had caused two crashes and one injury, according to the automaker.
Where we start to see behind the veil is in the defect notice freshly released by NHTSA. It shows that GM began investigating more widely for ignition switches in April, shortly after the company expanded its ignition switch recall to a variety of Saturn products, among others, according to Automotive News. The automaker found 152 reports in the 2002-2004 Vue of vehicles rolling away or the key being removed out of a total population of 215,243 units worldwide.

Junkyard Gem: 2004 Saturn Vue with manual transmission

GM's Saturn Division has been gone since the final 2010 Auras, Outlooks, Skies, and Vues slunk apologetically out of the showrooms, and I'm doing my best to document the more interesting models from The General's once-revolutionary brand. Some of the later Saturns began life as Opel designs, but the Vue actually was the first vehicle to go on the all-new GM Theta platform; the Opel Antara was thus a Saturn copy, a fact that Saturn fans no doubt trot out when they get shamed by Opel zealots over the Astra. Today's Junkyard Gem is a most unusual Vue, in the sense that its original purchaser was fine with both the base manual transmission and the leather-upholstery upgrade. Sure, the cheapest way to buy a new Vue— which was sold here for the 2002-2007 model years— was to get it with the base transmission: a five-speed manual. You can still buy a new car with a five-on-the-floor manual right now, but only in a handful of cheapmobiles; by the middle 2000s, a tiny-and-ever-shrinking subset of American car shoppers would even consider a three-pedal commuter vehicle. Really, there were only two reasons an American new-car buyer would have considered a non-enthusiast vehicle with a manual transmission in 2004: either an eccentric preference for the good ol' stickshift or just plain penny-pinching. The cheapest possible '04 Vue was the version with four-cylinder 2.2-liter engine, front-wheel-drive, and five-speed manual transmission, and it started at $17,025 (about $26,080 in 2022 dollars). That's what we're looking at here. The optional CVT automatic transmission cost an additional $2,095 ($3,210 today), so it made sense to get the manual if you wanted to save serious money on your Vue. However, this car is loaded to the gunwales with nice equipment upgrades, to the tune of at least the Leather Appointments Package ($755) and the Sports Plus II Package ($1,300) and probably a lot more.  So, a buyer who didn't care about power (so no V6 engine), didn't want all-wheel-drive, liked driving a manual transmission Â… but insisted on power everything and a full-zoot comfy leather interior Â… in a cheap small SUV sold by a fast-fading brand. The conversations with the Saturn salesmen about this thing must have been interesting. Built in Tennessee, sold new in Denver, will be crushed near Pikes Peak.

VIDEO: Saturn's demise? We blame Jim Gaffigan*

Click above to view the video after the jump
When the deal to sell Saturn to Penske Automotive fell through, there were likely a lot of surprised people at General Motors' Detroit, MI headquarters. Penske released a statement saying that the reason the deal fell through after months of good faith negotiations was that a suitable post-GM supply of vehicles could not be found. However, after reacquainting ourselves with over eight minutes of outtakes from Jim Gaffigan's old Saturn commercial, we're thinking the comedic pitchman is to blame.