2024 Ram 4500hd Tradesman on 2040-cars

Auto blog

FCA recalls 2 million Ram trucks over airbag issues

Airbag issues have prompted Fiat Chrysler Automobiles to issue another pair of recalls. The two separate issues both affect Ram pickups, one campaign stemming from oversensitive sensors, the other from a wiring harness. Between them, the problems affect an estimated combined total of some 2 million units. The first recall affects 2013-15 Ram 1500, 2500, and 3500 trucks, specifically four-door models, manufactured between June 20, 2012, and January 26, 2015. The calibration of the side impact sensor in those affected units may to be too sensitive. As a result, if the door is slammed too hard, the side-curtain airbag and seatbelt pre-tensioner may inadvertently activate. FCA reports that this issue affects an estimated 667,406 units in the United States, plus 153,011 in Canada, a further 8,272 in Mexico, and another 14,847 in markets outside of North America, amounting (in Chrysler's estimation) to less than 0.005 percent of those vehicles produced. The automaker says it is aware of two minor injuries (but no accidents) that may have resulted from the glitch, and is taking action to have the Occupant Restraint Control module recalibrated in the affected units. The second issue also affects Ram pickups, including 1500, 2500, 3500, 4500, and 5500-series models from the 2012 to 2014 model years, built between January 18, 2011, and October 7, 2014, and fitted with the optional Electronic Vehicle Information Center. The problem here stems from a wiring harness in the steering wheel that may rub against a retainer spring in the air bag control module, which in turn could cause an electrical short and deploy the driver's side air bag unexpectedly. In the United States alone, the issue is estimated to affect 1,060,531 units, which will need to be inspected and, where necessary, have their steering wheel wiring harnesses secured, with protective caps added to the ends of the airbag retainer spring. These do not represent the first issues we've seen from Fiat Chrysler in recent days. The automaker recently issued a recall for approximately 1.4 million vehicles to have their Uconnect software updated to prevent hacking. A few days ago it also announced a recall for 350,000 Dodge Journey (and Fiat Freemont) crossovers to secure loose engine covers. And the National Highway Traffic Safety Administration is expected to issue Fiat Chrysler Automobiles a $105-million fine for mishandling other recent recalls and safety issues.

Feds sue Fiat Chrysler, accuse it of cheating on diesel emissions

WASHINGTON - The US government has filed a civil lawsuit accusing Fiat Chrysler Automobiles NV of using software to bypass emission controls in diesel vehicles. The Justice Department suit, filed in US district court in Detroit, is a procedural step that may ramp up pressure on Fiat Chrysler. The suit could ultimately help lead to a settlement, as in an earlier probe of rival Volkswagen AG that will cost VW up to $25 billion, but which affected a much larger number of vehicles. VW admitted to intentionally cheating while Fiat Chrysler denies wrongdoing. It did not immediately comment on Tuesday. US-listed Fiat Chrysler shares were down 2.9 percent at $10.44. The suit also names Fiat Chrysler's unit V.M. Motori SpA, which designed the engine in question. Reuters reported last week the Justice Department and EPA have obtained internal emails and other documents written in Italian that look at engine development and emissions issues that raise significant questions. The investigation has scrutinized VM Motori. FCA acquired a 50 percent stake in VM Motori in 2010 and the remainder in October 2013. The lawsuit asserts the Italian-American automaker placed undeclared "defeat devices," or auxiliary emissions controls, in 2014-2016 Fiat Chrysler diesel vehicles that led to "much higher" than allowable levels of nitrogen oxide, or NOx pollution, which is linked to smog formation and respiratory problems. The suit seeks injunctive relief and unspecified civil penalties. EPA said in January the maximum fine is about $4.6 billion. In January, EPA and California accused Fiat Chrysler of illegally using undisclosed software to allow excess diesel emissions in 104,000 U.S. 2014-2016 Jeep Grand Cherokees and Dodge Ram 1500 trucks. Fiat Chrysler said on Friday it plans to update software that it expects will resolve the concerns of U.S. regulators about excess emissions in those vehicles. The January notice was the result of regulators' investigation of rival Volkswagen, which prompted the government to review emissions from all other passenger diesel vehicles. Volkswagen admitted in September 2015 to installing secret software allowing its cars to emit up to 40 times legal pollution levels. In total, VW has agreed to spend up to $25 billion in the United States to address claims from owners, environmental regulators, states and dealers and offered to buy back about 500,000 polluting US vehicles.

Pickup prices rising at 2x industry average

We've said it before, but bears repeating: Pickup trucks are the financial engines of America's automakers. Good thing, then, that the segment is in rude health - in fact, Automotive News is suggesting that pickup truck sales are arguably healthier than they were pre-recession, even though the segment's volume is still significantly down from where it was before the bottom fell out of the US economy. That's because per-unit profits on full-size trucks are skyrocketing, outpacing the industry's average price increases by more than double since 2005. According to data from Edmunds, the average transaction price of a full-size pickup is now $39,915 - a heady increase over the $31,059 average price in 2005 - a gain of over 8 percent after inflation is factored in.
Just how important are trucks to automakers' bottom lines? Automotive News quotes a Morgan Stanley analyst as saying the Ford F-Series is responsible for 90 percent of the company's 2012 profits, and General Motors isn't far behind, with the Chevrolet Silverado and GMC Sierra twins chipping in about two-thirds of the automaker's earnings.
Automotive News points out that Detroit's automakers now have the money to invest in modernizing their full-size truck offerings, in part because they don't have the same overhead and legacy costs that pushed General Motors and Chrysler into bankruptcy. Certainly, the pickup segment has seen a lot of innovations as of late, including turbocharged V6s, coil-spring rear suspensions and active aero. Those improvements in important areas like fuel economy and ride comfort have given existing pickup buyers new reasons to upgrade. In addition, automakers are piling on the tech and luxury goodies, creating more and more high-content, high-profit models like the Ford F-150 King Ranch, Ram 1500 Laramie Longhorn and Chevrolet Silverado High Country (shown).