2014 Ram 2500 Tradesman on 2040-cars

Auto blog

Ram recalling 1,747 diesel trucks for short-circuit risk

Diesel-powered Ram owners, it's recall time. Fiat Chrysler Automobiles has announced a voluntary recall of 1,747 Ram 1500 EcoDiesels from model years 2014 and 2015. Why so few? Well, this campaign is limited to just rear-wheel-drive models. The problem, this time around, is with a battery wiring harness that will chafe against a bracket if it wasn't assembled properly. This chaffing can lead to a short, causing a loss of power (the best-case scenario) or even a fire (probably the worst-case scenario). Fortunately, FCA is unaware of any accidents, fires, or other injuries caused by short circuits. The affected vehicles were sold in both the US and Canadian markets, although the vast majority of the trucks, 1,697 to be precise, are here in the land of the free and home of the brave. The remaining 50 vehicles were sold in Canada, and were likely purchased by those crazy enough to drive a high-torque, rear-drive pickup in a country almost perpetually covered in snow and ice. Regardless of whether your truck has an illuminated dashboard warning light or not, FCA is encouraging drivers of the affected vehicles to report to dealers for a free service when they receive a recall notice. Scroll down for the official press release from FCA, as well as the bulletin from the National Highway Traffic Safety Administration. Statement: Wiring Harness September 9, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 1,747 trucks in the U.S. and Canada to inspect, reroute and replace – as required – their wire harnesses to prevent a potential short-circuit. An investigation by FCA US discovered a battery wiring harness may chafe against a bracket if assembly protocols were not followed. This condition is limited to vehicles equipped with diesel engines and 4x2 drivelines. Such a condition has the potential to cause a short-circuit, which may lead to power loss or fire. The Company is unaware of any related injuries, accidents or fires. The campaign is limited to certain 2014-15 Ram 1500 pickups. It is estimated there are 1,697 in the U.S. and 50 in Canada. Affected customers will be advised next month when they may schedule service, which will be performed at no cost. While the condition may not be present in every vehicle, FCA US urges customers to note the information on their recall notices and respond accordingly. Illumination of a dashboard warning light is among the indicators that the condition is present.

Ford F-150 could be affected by tornado-damaged supplier in S.C.

The disruption caused by a tornado that severely damaged a South Carolina auto-parts plant and killed a contract security guard last week could be felt by more automakers than just Ford and affect more than just its best-selling F-Series pickup, which is due for an update. And there’s still no estimate for when operations might resume at the plant. The Detroit Free Press reports that the BorgWarner plant in Seneca, near Greenville, makes transfer cases for F-150 and Super Duty pickups, the Ford Explorer and Expedition, Transit cargo vans, and Lincoln Navigator and Aviator SUVs. ItÂ’s also a supplier for the Ram 1500 and Toyota Tundra trucks. Transfer cases shift power from the transmission to the front and rear axles in four-wheel-drive vehicles. BorgWarner says it still has no update for when it might partially or fully resume operations. The tornado that ripped through the area in the western part of the state on April 13 tore the roof, walls and signage off the factory and killed a 77-year-old contract worker when the security building he was sheltering in collapsed. Only four or five others were inside the plant, which has been idled because of the coronavirus outbreak, when the tornado struck. In an SEC filing on Friday, Ford said it has sent employees to the site to help BorgWarner and assess the damage to FordÂ’s tooling. “Initial assessments indicate that the Ford tooling was not materially damaged in this incident,” Ford said in the filing. “We do not have sufficient information to estimate when the facility will be back on-line or whether or the extent to which this incident will impact our plans to resume production of four-wheel drive and all-wheel drive vehicles.” A Fiat Chrysler spokeswoman also told the Freep the company was working with BorgWarner on recovery plans. A Toyota spokesman told Autoblog that "we are collaborating with BorgWarner to help restore production for transfer cases for Tundra assembly. We are confident that theyÂ’ll fully recover over time." Like other automakers, Ford shut down production at its U.S. plants last month as a precaution against the coronavirus pandemic. But Ford hasnÂ’t yet said when it plans to reopen its factories. FCA is targeting May 4 to resume production. Models like the F-150 and Lincoln Navigator are major sources of profit for Ford, which estimated it lost $2 billion in the first quarter.

Auto journo learns hard way that new vehicles burn differently than old ones

Terry Box, a writer for the Dallas Morning News, was tootling down the Dallas North Tollway in a Ram 1500 Laramie Longhorn pickup after work and enjoying the ride. Box thought the $53,335, option-filled press loaner had been "flawless - very serious competition for anything built by Ford or Chevy." And then, for reasons that still aren't clear, something in the engine compartment caught fire and the Ram cremated itself on the shoulder of an off-ramp.
Box tells the story and it isn't an indictment of the truck, but a cautionary tale about how new vehicles don't burn like the old ones did - and why not to go back for your gym bag. It could also be a kind reminder about what kind of safety gear everyone should keep in their cars. Click the link to read the whole piece.