2012 Ram 1500 St on 2040-cars

Auto blog

Ram recalling 1,747 diesel trucks for short-circuit risk

Diesel-powered Ram owners, it's recall time. Fiat Chrysler Automobiles has announced a voluntary recall of 1,747 Ram 1500 EcoDiesels from model years 2014 and 2015. Why so few? Well, this campaign is limited to just rear-wheel-drive models. The problem, this time around, is with a battery wiring harness that will chafe against a bracket if it wasn't assembled properly. This chaffing can lead to a short, causing a loss of power (the best-case scenario) or even a fire (probably the worst-case scenario). Fortunately, FCA is unaware of any accidents, fires, or other injuries caused by short circuits. The affected vehicles were sold in both the US and Canadian markets, although the vast majority of the trucks, 1,697 to be precise, are here in the land of the free and home of the brave. The remaining 50 vehicles were sold in Canada, and were likely purchased by those crazy enough to drive a high-torque, rear-drive pickup in a country almost perpetually covered in snow and ice. Regardless of whether your truck has an illuminated dashboard warning light or not, FCA is encouraging drivers of the affected vehicles to report to dealers for a free service when they receive a recall notice. Scroll down for the official press release from FCA, as well as the bulletin from the National Highway Traffic Safety Administration. Statement: Wiring Harness September 9, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 1,747 trucks in the U.S. and Canada to inspect, reroute and replace – as required – their wire harnesses to prevent a potential short-circuit. An investigation by FCA US discovered a battery wiring harness may chafe against a bracket if assembly protocols were not followed. This condition is limited to vehicles equipped with diesel engines and 4x2 drivelines. Such a condition has the potential to cause a short-circuit, which may lead to power loss or fire. The Company is unaware of any related injuries, accidents or fires. The campaign is limited to certain 2014-15 Ram 1500 pickups. It is estimated there are 1,697 in the U.S. and 50 in Canada. Affected customers will be advised next month when they may schedule service, which will be performed at no cost. While the condition may not be present in every vehicle, FCA US urges customers to note the information on their recall notices and respond accordingly. Illumination of a dashboard warning light is among the indicators that the condition is present.

Fiat Chrysler expands Takata airbag recall to 3.3M vehicles

Fiat Chrysler Automobiles is expanding its recall of vehicles equipped with Takata airbags, moving beyond Florida, Hawaii, Puerto Rico and the US Virgin Islands to the greater US, as well as Mexico, Canada and beyond. The affected vehicles, some 3.3 million in total, were built between 2004 and 2007, with many models, including the Dodge Ram 1500, 2500 and 3500, Durango and the Chrysler 300, having been affected by Chrysler's previous recall. Despite the somewhat alarming nature that comes with a recall of this many vehicles, it seems that Chrysler is moving more out of an abundance of caution (and federal pressure) than anything else, saying: "Neither FCA US, nor Takata Corporation, the supplier, has identified a defect in this population of inflators. These components also are distinct from Takata inflators cited in fatalities involving other auto makers. More than 1,000 laboratory tests have been performed on these components. All deployed as intended, but FCA US continues to study the suspect inflators, which are not used in the Company's current production vehicles." Owners of affected vehicles will be notified and asked to report to dealers for a free replacement driver's side airbag. Scroll down for the official press release from FCA. Statement: Global Air-Bag Inflator Replacement December 19, 2014 , Auburn Hills, Mich. - FCA US LLC will replace driver's-side air-bag inflators in an estimated 3.3 million older-model vehicles worldwide, in an expansion of an ongoing regional field action. Neither FCA US, nor Takata Corporation, the supplier, has identified a defect in this population of inflators. These components also are distinct from Takata inflators cited in fatalities involving other auto makers. More than 1,000 laboratory tests have been performed on these components. All deployed as intended, but FCA US continues to study the suspect inflators, which are not used in the Company's current production vehicles. Outside of Florida, one of the areas covered by the original action, no FCA US vehicle has been linked to an air-bag deployment of the type that has raised public concern. Nevertheless, the Company is replacing the Takata components tied to that concern. FCA US is aware of one related injury involving one of its vehicles, an older-model sedan. It occurred in a southern Florida region marked by persistent, high, absolute humidity – a condition believed to be a contributing factor in the air-bag deployments under investigation.

Ram issues recall on heavy-duty pickup transfer cases

UPDATE: A previous version of this story said the issue only occurred in four-wheel drive. This is incorrect – issues are only exhibited in two-wheel drive. The Basics: Ram is recalling 930 3500, 4500, and 5500 heavy-duty pickups from model year 2016. The affected 3500s were built between July 24, 2015 and January 7, 2016, while the larger 4500/5500 trucks were screwed together between July 24, 2015 and October 8, 2015. The Problem: According to the official NHTSA bulletin, the "transfer case may have been manufactured with a misshapen main output shaft, creating voids that may cause a shaft fracture." If this happens, the vehicle could lose power. The driver might not be able to select park, either. Injuries/Deaths: FCA isn't aware of any injuries or deaths related to the issue. The Fix: Dealerships will replace the transfer case on affected trucks. If you own one: You probably don't. According to FCA spokesman Eric Mayne, dealers haven't delivered the majority of the affected trucks to customers. But if you really do own one, Mayne added that the issue only occurs in two-wheel drive. We'd advise keeping it in four-wheel drive until you can report to your local dealer. FCA kicked the recall off on August 10, so expect a mailed notification soon. Related Video: