Clean on 2040-cars

Auto blog

GM recalling 70k Chevy Malibus, Pontiac G6s over steering issue

A problem with the power steering system in the Chevy Malibu and Pontiac G6 has prompted General Motors and the National Highway Traffic Safety Administration to issue a recall for an estimated 69,633 vehicles. The issue revolves around the electric power steering assist, which could suddenly fail and increase the risk of a crash, especially at low speeds where the power steering is most helpful. The recall affects 2006-2007 Chevy Malibu sedans and Malibu Maxx wagons (specifically those manufactured between April 1, 2006, and June 30, 2006), as well as the Pontiac G6 (which was offered as a sedan, coupe or convertible) from the same model years and manufactured from April 18, 2006, to June 30, 2006. Owners of the affected units can expect to hear from the manufacturer with instructions to bring in their vehicles to their local dealers to have the torque sensors in the power steering system replaced. RECALL Subject : Sudden Loss of Electric Power Steering , 1 INVESTIGATION(S) Report Receipt Date: FEB 04, 2015 NHTSA Campaign Number: 15V064000 Component(s): STEERING Potential Number of Units Affected: 69,633 Manufacturer: General Motors LLC SUMMARY: General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving. CONSEQUENCE: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash. REMEDY: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

GM recalls 61k more vehicles in three campaigns

Following a stop-delivery order for its new midsize trucks and a rash of recent recalls, General Motors is issuing three more campaigns covering 60,575 vehicles in North America with 57,182 of them in the US. As of October 1, the automaker has issued a total of 74 recalls (see the ridiculously long chart to the right) this year covering 26,495,070 units in the US.
The largest campaign covers 46,873 examples in the US of the 2008-2009 Pontiac G8 and 2011-2013 Chevrolet Caprice Police Patrol Vehicle imported from Australia. It's possible for the driver's knee to hit the key and make it move from the "Run" to "ACC" position while driving. GM says its Holden division is developing a fixed-blade key that's supposed to fix the problem by only allowing it to rotate toward the "On" position. There has been one crash caused by this fault but no injuries or fatalities.
The second recall is for 10,005 units of the 2004-2007 Cadillac CTS-V and 2006-2007 Cadillac STS-V because "the fuel pump module electrical terminal may overheat." This can cause a flange to melt and allow the pump to leak fuel. GM specifies that the remedy for the CTS-V is replacing the fuel module and fuel tank jumper harness, but it doesn't specify how the STS-V is being repaired.

GM's got 107 problems and NHTSA's No. 1

General Motors' problems with its recall of roughly 1.6-million vehicles continue to mount. Now that it has emerged that GM knew about the problem since at least 2004 but waited to recall vehicles until February 2014, regulators at the National Highway Traffic Safety Administration have begun a much deeper investigation. NHTSA has sent a 27-page survey to GM that includes 107 questions about the timeline of what led up to the recall, and it has until April 3 to reply. This isn't a simple, multiple-choice test. Automotive News believes that hundreds of pages could be required to answer some of the queries. NHTSA says that it is still investigating GM's response to the recall. "We are a data-driven organization, and we will take whatever action is appropriate based on where our findings lead us," said NHTSA in a statement on its website. If found liable, the automaker could face a fine as high as $35 million and even possible criminal charges, according to Bloomberg. NHTSA's questions include a detailed explanation of GM's examination process; how it will improve the process; why a planned redesign of the cars' key in 2005 wasn't implemented; and specific data on each complaint it received. According to Bloomberg, NHTSA also has records that show the company had a meeting with regulators to discuss the airbag failure in a Chevrolet Cobalt in 2007. New GM CEO Mary Barra has also hired an outside law firm to conduct an independent investigation about what happened. It will include questioning company employees who were involved with the process from the start. The recall stems from faulty ignition switches that shut off the car while driving, and if it occurs the airbags deactivate. Thirteen deaths and 23 crashes have been caused by the problem, according to Bloomberg. If you would like to peruse NHTSA's entire questionnaire for GM, it can be viewed here. News Source: Automotive News – sub. req., National Highway Traffic Safety Administration, BloombergImage Credit: Carlos Osorio / AP / dapd Government/Legal Recalls GM Pontiac Saturn Safety pontiac solstice saturn ion saturn sky pontiac g5